Abstract:Zinc oxide (ZnO) films with thicknesses from (9.1 +/- 0.7) to (145 +/- 7) nm were deposited on silicon substrates by ion-assisted electron beam evaporation (EBE), and transformed to a highly (110)-oriented non-polar phase through thermal treatment at temperatures of 300, 500, and 700 degrees C. The structural, morphological and optical properties of the ZnO thin films were systematically characterized using transmission electron microscopy (TEM), X-ray diffraction (XRD), atomic force microscopy (AFM), spectroscopic ellipsometry (SE), and photoluminescence (PL). The XRD and AFM results illustrate that the deposited ZnO films evolved from an X-ray amorphous structure to the polycrystalline hexagonal wurtzite structure with increasing thickness and experienced a crystallographic plane improvement from (102) to the (110) non-polar phase during annealing. The dielectric functions of the whole layer are mainly affected by the dielectric responses near the surface of ZnO nanocrystals and show an upward trend with nanocrystal growth, induced by thickness and annealing temperature. The optical band gaps were also investigated and correlated with the structural properties. In the PL spectra, a strong ultraviolet luminescence (UVL) band and a weak visible green luminescence (GL) band were observed. The intensity ratio of UVL and GL-associated with crystal quality-agrees with the results acquired from other measurements. The two determinants for highly (110)-oriented non-polar ZnO films are the suppression of growth in the (002) direction by ion bombardment and the promotion of the (110) plane induced by diffusion energy during annealing. (C) 2017 Elsevier B.V. All rights reserved.

The c-axis oriented ZnO thin films deposited by in situ sputtering at low temperature

The growth of nanoscale ZnO films by pulsed-spray evaporation chemical vapor deposition and their structural, electric and optical properties

Microstructure and Optical Properties of ZnO Films Deposited by Radio-frequency Reactive Magnetron Sputtering

Deposition and Characterization of AZO Thin Films on Flexible Glass Substrates Using DC Magnetron Sputtering Technique

The Effects of Oxygen Partial Pressure and Substrate Temperature on the Structural and Optical Properties of Zno Films

Effect of Nucleation and Growth Kinetics on the Electrical and Optical Properties of Undoped ZnO Films

STRUCTURAL AND OPTICAL STUDIES OF ZnO FILMS GROWN AT LOW TEMPERATURE

Deposition Condition Investigation of High c-axis Preferred Orientation ZnO Films Produced by RF Magnetron Sputtering

Comparison of Structural and Optical Properties of ZnO Films Grown on Different Substrates at Low Temperatures

Physical and Optical Properties of ZnO Thin Films Grown by DC Sputtering Deposition

Influence of Sputtering Power on Properties of ZnO Thin Films Fabricated by RF Sputtering in Room Temperature

Structural and Optical Characterizations of ZnO Films Grown by Reactive Electron Beam Evaporation

Crystal Growth of Undoped ZnO Films on Si Substrates under Different Sputtering Conditions

Low-Temperature C-Axis Oriented Growth of Nanocrystalline Zno Thin Films on Si Substrates by Plasma Assisted Pulsed Laser Deposition

Room-temperature Remote-Plasma Sputtering of C-Axis Oriented Zinc Oxide Thin Films

Structural and Optical Properties of Highly (110)-Oriented Non-Polar ZnO Evaporated Films on Si Substrates

Deposition and Characterization of Sputtered ZnO Films

Low-Temperature Epitaxy Of Zno Films On Si(001) And Silica By Reactive E-Beam Evaporation

Structural, optical and electrical properties of ZnO thin films prepared by reactive deposition

Effect of the Substrate Temperature on the Property of ZnO Films Deposited by Magnetron Sputtering with DC at the Low Power

Preferential growth of ZnO thin films by the atomic layer deposition technique