Abstract:With the continued device scaling and the introduction of new device structures, MOSFET reliability phenomena arising from the hot carrier injection (HCI) stress have received extensive attention from both the academia and the industry community. In this work, the degradations of ultra-scaled silicon on insulator (SOI) MOSFETs under the HCI stress are investigated on devices of different gate lengths (L=30-150 nm). Our experimental data demonstrate that the time evolutions of the threshold voltage change (Vth) under the HCI stress for different gate length devices are the same, and the magnitude of Vth reduces for the shorter devices. The degradation of the device under the HCI stress should be due to both the channel hot carrier (CHC) effect and the bias temperature instability (BTI) effect. The distribution and magnitude of the electric field along the MOSFET's channel are analyzed. It is confirmed that besides the well-known CHC effect in the depletion region close to the drain side, a strong BTI effect co-exists in the channel close to the source side. This degradation mechanism is different from the conventional HCI stress. With the gate length decreasing, the contribution of the aforementioned BTI effect becomes larger, and it dominates in the degradation. One feature of the BTI effects is that the corresponding degradation is small when the gate length is short. This is consistent with our experimental result that the change of Vth is small for the device of short gate length under the accelerated HCI stress. The time evolution of Vth can be described by the equation Vth=A•tn, where A is a constant, t is the stress time, and n is the power law exponent obtained by the curve fitting. In this study, the power law exponent n of pMOSFET is larger than that of nMOSFET. This experimental fact can lead to the point that the BTI effect exists during the HCI stress because the BTI effect in ultra-scaled pMOSFETs is more significant than that in nMOSFETs. The stress-recover experiments of the HCI stress on MOSFTTs show larger recovery in device of shorter gate length. It is found that the ratio of the recovery to the total degradation in the 30 nm gate-length device is almost twice as large as that in the 150 nm device. The degradation from the CHC effect has no recovery, and the larger recovery in the shorter-channel device implies the larger component of the BTI degradation. Another intriguing fact is that our experimental result on SOI MOSFET is inconsistent with the recently reported result on FinFET. We argue that the reported stronger HCI degradation in FinFET may not be ascribed only to the stronger electric field in the shorter channel, but also to the fact that the FinFET' channel is three-dimensionally surrounded by the gate dielectric. This kind of three-dimensional structure significantly increases the chance for electrons or holes to be injected into the dielectric layer. Therefore the HCI reliability of planar SOI MOSFETs may be better than that of FinFETs at the same level of gate length. In conclusion, the BTI effect is an important source of the degradation during the HCI stress in ultra-short-channel device, and it is no more negligible in analyzing the underlying physical mechanism.

The Breakdown Characteristics of Ultra-Thin Gate Oxide N-Mosfet under Voltage Stress

Off-state Avalanche-Breakdown-induced On-Resistance Degradation in SGO–NLDMOS

Substrate and process dependence of gate oxide reliability of dual gate CMOS process

A Thorough Study of Quasi-Breakdown Phenomenon of Thin Gate Oxide in Dual-Gate CMOSFET's

Off-state Avalanche Breakdown Induced Degradation in 20 V NLDMOS Devices

Hot-carrier-induced On-Resistance Degradation of Step Gate Oxide NLDMOS

Substrate and Process Dependence of Gate Oxide Reliability of 0.18μm Dual Gate CMOS Process

The TDDB Characteristics of Ultra-Thin Gate Oxide MOS Capacitors under Constant Voltage Stress and Substrate Hot-Carrier Injection

A comprehensive analysis of breakdown mechanisms in 4H-SiC MOSFET and JFET

Breakdown Voltage of Ultrathin Dielectric Film Subject to Electrostatic Discharge Stress

Terminal Breakdown Voltage Degradation by Avalanche Stress Induced Hot-Hole Injection in Split Gate Trench Power MOSFET

TDDB Characteristics of Ultra-Thin HfN/HfO/sub 2/ Gate Stack

Stress induced leakage current and time dependent dielectric breakdown characteristics of ultra-thin HFO2 gate dielectrics

Study of Drain-Extended Nmos under Electrostatic Discharge Stress in 28 Nm and 40 Nm Cmos Process

Gate Length Dependence of Hot Carrier Injection Degradation in Short Channel Silicon on Insulator Planar Mosfet

Investigation of Failure Mechanisms of 1200V Rated Trench SiC MOSFETs under Repetitive Avalanche Stress

Modeling of Charge-to-Breakdown with an Electron Trapping Model for Analysis of Thermal Gate Oxide Failure Mechanism in SiC Power MOSFETs

Investigation of Breakdown Voltage Degradation in Low-Voltage Narrow Gate Trench MOSFET by Edge Termination Optimization

Investigation of ultra-thin SiO/sub 2/ gate oxide characteristics

Impact of Electrical Stress on Defect Generation in Thin GeO<sub>2</sub>/Ge Gate Stacks Fabricated by Thermal Oxidation

Influence of Different Device Structures on the Degradation for Trench-Gate SiC MOSFETs: Taking Avalanche Stress as an Example