Abstract:Selective Catalytic Reduction (SCR) system can efficiently remove NOx in coal-fired power plant, while raise SO3 concentration in the flue gas. Alkaline sorbent injection is a major approach to remove SO3. Experiments were conducted to study the SO3 absorption performance of alkaline sorbent. The SO3 absorption performance of the three alkaline sorbents was Na2CO3 > Ca(OH)(2) approximate to Mg(OH)(2). The ratio of SO3 absorption rate to SO2 absorption rate for Na2CO3 increased with the increasing temperature. The key parameters on the SO3 absorption performance of Na2CO3 were studied. The SO3 absorption by Na2CO3 was increased by 72.7% with increasing temperature from 150 degrees C to 300 degrees C, and the temperature had little influence on SO3 absorption above 300 degrees C. The increasing SO3 concentration and decreasing particle size of Na2CO3 enhanced SO(3 )absorption. However, when the average particle diameter was less than 50 the SO3 absorption was no longer significantly increased. The increasing CO2 concentration slightly reduced the SO3 absorption. After adding vapor into the flue gas, the SO3 absorption was obviously increased below 300 degrees C. The SO3 absorption variation above 300 degrees C was similar to the condition without vapor. When reaction temperature was 300 degrees C or above and reaction time was less than 20 min, external diffusion became the control step for SO3 absorption. On the basis of external diffusion control model, the mass transfer coefficient slightly increased from 1.68 x 10(-3)m/s to 1.75 x 10(-3) m/s when the reaction temperature increased from 300 degrees C to 400 degrees C.

Nitrogen Dioxide Reaction With Calcium Based Sorbent During Dry Flue Gas Desulfurization

Simultaneous Removal of SO2 and NO from Flue Gas with Calcium-Based Sorbent at Low Temperature

Simultaneous Removal of SO2 and NOx by Calcium-Based Sorbent with NH3 Injection at Moderate Temperatures

Simultaneous Absorption of SO2 and NO from Flue Gas with CaCO3 and Liquid Phase Oxidation

Effect of SO2 on NO removal by calcium hydroxide

Study on desulfurization reaction characteristic of calcium-based sorbents

Experimental Research On No2'S Effect On Dry Fgd Reaction At Medium Temperature

Simultaneous removal of SO2 and NOx by calcium hydroxide at low temperature: Effect of SO2 absorption on NO 2 removal

Evolution of Pore Structure of Ca-based Sorbent in Simultaneous Removal of SO_2 and NO_x

Effect of Additive Agents on the Simultaneous Absorption of No2 and So2 in the Calcium Sulfite Slurry

Chain Reaction Mechanism by NO<i><sub>x</sub></i>in SO<sub>2</sub>Removal Process

Simultaneous removal of SO 2 and NO from coal flue gas with NaClO 2/ KMnO 4 enhanced Ca-based sorbent

Simultaneous Reduction of SO2 and NOx in an Entrained-Flow Reactor

Enhancement Mechanism of SO2 Removal with Calcium Hydroxide in the Presence of NO2

Reaction mechanism of NO and SO2 Co-removal by calcium hydroxide

Effect of NO on dry flue gas desulfurization reaction at 250-500°C

Experimental research and mechanism analysis of NO2's effect on dry FGD reaction at 250∼500 °c

Experimental Study on the Denitrification Performance of Calcium-based Sorbent of Mid-temperature Dry Method

Simultaneous removal of SO2 and NO by using calcium absorbent with KMnO4 as additive

Experimental Study on the Removal of SO3 from Coal-Fired Flue Gas by Alkaline Sorbent

Enhanced absorption process of NO2 in CaSO3 slurry by the addition of MgSO4