Abstract:Selective Catalytic Reduction (SCR) system can efficiently remove NOx in coal-fired power plant, while raise SO3 concentration in the flue gas. Alkaline sorbent injection is a major approach to remove SO3. Experiments were conducted to study the SO3 absorption performance of alkaline sorbent. The SO3 absorption performance of the three alkaline sorbents was Na2CO3 > Ca(OH)(2) approximate to Mg(OH)(2). The ratio of SO3 absorption rate to SO2 absorption rate for Na2CO3 increased with the increasing temperature. The key parameters on the SO3 absorption performance of Na2CO3 were studied. The SO3 absorption by Na2CO3 was increased by 72.7% with increasing temperature from 150 degrees C to 300 degrees C, and the temperature had little influence on SO3 absorption above 300 degrees C. The increasing SO3 concentration and decreasing particle size of Na2CO3 enhanced SO(3 )absorption. However, when the average particle diameter was less than 50 the SO3 absorption was no longer significantly increased. The increasing CO2 concentration slightly reduced the SO3 absorption. After adding vapor into the flue gas, the SO3 absorption was obviously increased below 300 degrees C. The SO3 absorption variation above 300 degrees C was similar to the condition without vapor. When reaction temperature was 300 degrees C or above and reaction time was less than 20 min, external diffusion became the control step for SO3 absorption. On the basis of external diffusion control model, the mass transfer coefficient slightly increased from 1.68 x 10(-3)m/s to 1.75 x 10(-3) m/s when the reaction temperature increased from 300 degrees C to 400 degrees C.

Experimental Study on the Denitrification Performance of Calcium-based Sorbent of Mid-temperature Dry Method

Experimental on simultaneous denitrification process of moderate temperature dry desulfurization system

Simultaneous Removal of SO2 and NOx by Calcium-Based Sorbent with NH3 Injection at Moderate Temperatures

Simultaneous Removal of SO2 and NO from Flue Gas with Calcium-Based Sorbent at Low Temperature

Simultaneous Absorption of SO2 and NO from Flue Gas with CaCO3 and Liquid Phase Oxidation

Novel Method for High-Performance Simultaneous Removal of NOx and SO2 by Coupling Yellow Phosphorus Emulsion with Red Mud

Effect of Fly Ash on the Denitrification Performance of NH_3 at Moderate Temperatures

Experimental Study on the Removal of SO3 from Coal-Fired Flue Gas by Alkaline Sorbent

Simultaneous Absorption of SO2 and NO from Flue Gas with KMnO4/CaCO3 Slurry

Experimental Study on Isothermal SNCR Process of NOx Removal

Simultaneous removal of SO 2 and NO from coal flue gas with NaClO 2/ KMnO 4 enhanced Ca-based sorbent

Nitrogen Dioxide Reaction With Calcium Based Sorbent During Dry Flue Gas Desulfurization

Experimental Study on Desulfurization Performance of Hot Gas at Medium and High Temperature

Simultaneous removal of SO2 and NO by using calcium absorbent with KMnO4 as additive

Simultaneous Reduction of SO2 and NOx in an Entrained-Flow Reactor

EXPERIMENTAL STUDIES ON DESULFURIZATION OF CALCIUM BASED SORBENT IN O2/CO2 COAL COMBUSTION

Experimental Research on Low Temperature Manganese Oxides SCR Denitrification for Oxy-Fuel Combustion Flue Gas

[Influence and Mechanism of Calcium-Based Desulfurizer on NO Conversion in Fluidized Bed of Coal].

Production and Performance of Coal Gasification Slag–Based Denitrification Materials in Cement Kilns

Experimental Study on Underground Coal Gasification As Multicomponent Reducing Gas for Denitrification

Experimental Study of Selective Non-catalytic Reduction of NO by NH_3