Abstract:With the continued device scaling and the introduction of new device structures, MOSFET reliability phenomena arising from the hot carrier injection (HCI) stress have received extensive attention from both the academia and the industry community. In this work, the degradations of ultra-scaled silicon on insulator (SOI) MOSFETs under the HCI stress are investigated on devices of different gate lengths (L=30-150 nm). Our experimental data demonstrate that the time evolutions of the threshold voltage change (Vth) under the HCI stress for different gate length devices are the same, and the magnitude of Vth reduces for the shorter devices. The degradation of the device under the HCI stress should be due to both the channel hot carrier (CHC) effect and the bias temperature instability (BTI) effect. The distribution and magnitude of the electric field along the MOSFET's channel are analyzed. It is confirmed that besides the well-known CHC effect in the depletion region close to the drain side, a strong BTI effect co-exists in the channel close to the source side. This degradation mechanism is different from the conventional HCI stress. With the gate length decreasing, the contribution of the aforementioned BTI effect becomes larger, and it dominates in the degradation. One feature of the BTI effects is that the corresponding degradation is small when the gate length is short. This is consistent with our experimental result that the change of Vth is small for the device of short gate length under the accelerated HCI stress. The time evolution of Vth can be described by the equation Vth=A•tn, where A is a constant, t is the stress time, and n is the power law exponent obtained by the curve fitting. In this study, the power law exponent n of pMOSFET is larger than that of nMOSFET. This experimental fact can lead to the point that the BTI effect exists during the HCI stress because the BTI effect in ultra-scaled pMOSFETs is more significant than that in nMOSFETs. The stress-recover experiments of the HCI stress on MOSFTTs show larger recovery in device of shorter gate length. It is found that the ratio of the recovery to the total degradation in the 30 nm gate-length device is almost twice as large as that in the 150 nm device. The degradation from the CHC effect has no recovery, and the larger recovery in the shorter-channel device implies the larger component of the BTI degradation. Another intriguing fact is that our experimental result on SOI MOSFET is inconsistent with the recently reported result on FinFET. We argue that the reported stronger HCI degradation in FinFET may not be ascribed only to the stronger electric field in the shorter channel, but also to the fact that the FinFET' channel is three-dimensionally surrounded by the gate dielectric. This kind of three-dimensional structure significantly increases the chance for electrons or holes to be injected into the dielectric layer. Therefore the HCI reliability of planar SOI MOSFETs may be better than that of FinFETs at the same level of gate length. In conclusion, the BTI effect is an important source of the degradation during the HCI stress in ultra-short-channel device, and it is no more negligible in analyzing the underlying physical mechanism.

Self-Heating Effect in Soi Mosfet'S

Heat Generation Mechanisms of Self-Heating Effects in Soi-Mos

Concurrent Analysis of Self-Heating Effect and Thermal Stress in Partially Insulated Field Effect Transistors (Pifets)

An Improved Model of Self-Heating Effects for Ultrathin Body SOI Nmosfets Based on Phonon Scattering Analysis

Electrothermal characterization of SOI FinFETs

Deep Insight of Self-Heating Effect Induced Hot Carrier Reliability Improvement in LDMOS Devices

Investigation of Self-Heating Effect in SOI Tunnel Field-Effect Transistor

The Simulation and Study of Self-heating Effects in Fully Depleted SOI MOSFETs

Electro-Thermal Analytical Model and Simulation of the Self-Heating Effects in Multi-Finger 4H-Sic Power Mesfets

Investigation of Self-Heating Effects in UTBB FD-SOI MOSFETs by a Modified Thermal Conductivity Model

Analytical workload dependence of self-heating effect for SOI MOSFETs considering two-stage heating process

Investigation of self-heating effect in SOI-LDMOS by device simulation

Heat dissipation path of self-heating effect for SOI MOSFET considering BOX layer and TiN barrier layer

The Heat Dissipation Path of Self-Heating Effects for the SOI MOSFET by Considering the BOX Layer and the TiN Barrier Layer

Analysis of Thermal Resistance Considering Self-Heating Effects and Ambient Temperature Coupling for Double-SOI MOSFETs

The Impact of Heat Loss Paths on the Electrothermal Models of Self-Heating Effects in Nanoscale Tri-Gate SOI MOSFETs

Analysis and Modeling of Geometry Dependent Thermal Resistance in Silicon-on-Insulator Metal–Oxide–Semiconductor Field-Effect Transistors

Gate Length Dependence of Hot Carrier Injection Degradation in Short Channel Silicon on Insulator Planar Mosfet

Study on the Thermal Conductivity Characteristics for Ultra-Thin Body FD SOI MOSFETs Based on Phonon Scattering Mechanisms

Temperature Evaluation of Conventional, SOI, and DSOI Mosfets Using Non-Equilibrium Energy Model

Self-heating effect in nanoscale SOI Junctionless FinFET with different geometries