Abstract:A larger (6.1 L) MFC stack made in a scalable configuration was constructed with four anode modules and three (two-sided) cathode modules, and tested at a wastewater treatment plant for performance in terms of chemical oxygen demand (COD) removal and power generation. Domestic wastewater was fed either in parallel (raw wastewater to each individual anode module) or series (sequentially through the chambers), with the flow direction either alternated every one or two days or kept fixed in a single direction over time. The largest impact on performance was the wastewater COD concentration, which greatly impacted power production, but did not affect the percentage of COD removal. With higher COD concentrations (similar to 500 mg L-1) and alternating flow conditions, power generation was primarily limited by the cathode specific area. In alternating flow operation, anode modules connected to two cathodes produced an average maximum power density of 6.0 +/- 0.4 W m(-3), which was 1.9 +/- 0.2 times that obtained for anodes connected to a single cathode. In fixed flow operation, a large subsequent decrease in COD influent concentration greatly reduced power production independent of reactor operation in parallel or serial flow modes. Anode modules connected to two cathodes did not consistently produce more power than the anodes connected to a single cathode, indicating power production became limited by restricted anode performance at low CODs. Cyclic voltammetry and electrochemical impedance spectroscopy data supported restricted anode performance with low COD. These results demonstrate that maintaining power production of MFC stack requires higher influent and effluent COD concentrations. However, overall performance of the MFC in terms of COD removal was not affected by operational modes. (C) 2016 Elsevier Ltd. All rights reserved.

A horizontal plug flow and stackable pilot microbial fuel cell for municipal wastewater treatment

A novel pilot-scale stacked microbial fuel cell for efficient electricity generation and wastewater treatment.

Scalable microbial fuel cell (MFC) stack for continuous real wastewater treatment.

Development of a Novel Membrane-less Microbial Fuel Cell (ML-MFC) with a Sandwiched Nitrifying Chamber for Efficient Wastewater Treatment

A pilot study on treatment of pig farm wastewater and electricity generation performance of microbial fuel cells

A 90-liter stackable baffled microbial fuel cell for brewery wastewater treatment based on energy self-sufficient mode

Microbial fuel cells with an integrated spacer and separate anode and cathode modules

The Effect of Fl Ow Modes and Electrode Combinations on the Performance of a Multiple Module Microbial Fuel Cell Installed at Wastewater Treatment Plant

Integration of Microbial Fuel Cell with Independent Membrane Cathode Bioreactor for Power Generation, Membrane Fouling Mitigation and Wastewater Treatment

Stacked all-graphite microfluidic microbial fuel cells

Microbial Fuel Cell Technology—A Critical Review on Scale-Up Issues

Floating flexible microbial fuel cells for electricity generation and municipal wastewater treatment

One-year operation of 1000-L modularized microbial fuel cell for municipal wastewater treatment

A Microbial Fuel Cell–membrane Bioreactor Integrated System for Cost-Effective Wastewater Treatment

In-situ integration of microbial fuel cell with hollow-fiber membrane bioreactor for wastewater treatment and membrane fouling mitigation.

A high performance membraneless microfluidic microbial fuel cell for stable, long-term benchtop operation under strong flow

Integrating Sludge Microbial Fuel Cell with Inclined Plate Settling and Membrane Filtration for Electricity Generation, Efficient Sludge Reduction and High Wastewater Quality

From single-chamber to multi-anodic microbial fuel cells: A review

Scale-up of Membrane-Free Single-Chamber Microbial Fuel Cells

Treatment of domestic sewage with anoxic/oxic membrane-less microbial fuel cell with intermittent aeration

Continuous Electricity Generation with Piggery Wastewater Treatment Using an Anaerobic Baffled Stacking Microbial Fuel Cell