Abstract:A larger (6.1 L) MFC stack made in a scalable configuration was constructed with four anode modules and three (two-sided) cathode modules, and tested at a wastewater treatment plant for performance in terms of chemical oxygen demand (COD) removal and power generation. Domestic wastewater was fed either in parallel (raw wastewater to each individual anode module) or series (sequentially through the chambers), with the flow direction either alternated every one or two days or kept fixed in a single direction over time. The largest impact on performance was the wastewater COD concentration, which greatly impacted power production, but did not affect the percentage of COD removal. With higher COD concentrations (similar to 500 mg L-1) and alternating flow conditions, power generation was primarily limited by the cathode specific area. In alternating flow operation, anode modules connected to two cathodes produced an average maximum power density of 6.0 +/- 0.4 W m(-3), which was 1.9 +/- 0.2 times that obtained for anodes connected to a single cathode. In fixed flow operation, a large subsequent decrease in COD influent concentration greatly reduced power production independent of reactor operation in parallel or serial flow modes. Anode modules connected to two cathodes did not consistently produce more power than the anodes connected to a single cathode, indicating power production became limited by restricted anode performance at low CODs. Cyclic voltammetry and electrochemical impedance spectroscopy data supported restricted anode performance with low COD. These results demonstrate that maintaining power production of MFC stack requires higher influent and effluent COD concentrations. However, overall performance of the MFC in terms of COD removal was not affected by operational modes. (C) 2016 Elsevier Ltd. All rights reserved.

One-year operation of 1000-L modularized microbial fuel cell for municipal wastewater treatment

Scalable microbial fuel cell (MFC) stack for continuous real wastewater treatment.

Development of a Novel Membrane-less Microbial Fuel Cell (ML-MFC) with a Sandwiched Nitrifying Chamber for Efficient Wastewater Treatment

A Microbial Fuel Cell–membrane Bioreactor Integrated System for Cost-Effective Wastewater Treatment

Potential of Novel Wastewater Treatment System Featuring Microbial Fuel Cell to Generate Electricity and Remove Pollutants

A novel pilot-scale stacked microbial fuel cell for efficient electricity generation and wastewater treatment.

Electricity Generation from Municipal Solid Waste Leachate Using Microbial Fuel Cell Technology

Treatment of Domestic Wastewater with Simultaneous Electricity Generation in Microbial Fuel Cell under Continuous Operation

A combined system of microbial fuel cell and intermittently aerated biological filter for energy self-sufficient wastewater treatment

A cooperative microbial fuel cell system for waste treatment and energy recovery

Electricity Generation from Organic Wastewater Using a Continuous-Flow Single Chamber Microbial Fuel Cell

Improving Electricity Generation and Substrate Removal of a MFC–SBR System Through Optimization of COD Loading Distribution

A Microbial Fuel Cell Producing Electricity Directly from Municipal Wastewater Treatment

The Effect of Fl Ow Modes and Electrode Combinations on the Performance of a Multiple Module Microbial Fuel Cell Installed at Wastewater Treatment Plant

In-situ integration of microbial fuel cell with hollow-fiber membrane bioreactor for wastewater treatment and membrane fouling mitigation.

Treatment of domestic sewage with anoxic/oxic membrane-less microbial fuel cell with intermittent aeration

Microbial fuel cells with an integrated spacer and separate anode and cathode modules

Microbial fuel cell in long-term operation and providing electricity for intermittent aeration to remove contaminants from sewage

Multi-anode enhanced the bioelectricity generation in air-cathode microbial fuel cells towards energy self-sustaining wastewater treatment

Transformation from biofiltration unit to hybrid constructed wetland-microbial fuel cell: Improvement of wastewater treatment performance and energy recovery