Abstract:Magnesium aluminate (MgAl2O4) spinel has grasped considerable attention in high-temperature application by right of its excellent properties. However, the poor sintering behavior of MgAl2O4 is detrimental to its further development. In the present work, the application of isostructural heterogeneous nucleation method provides a novel idea for optimizing the sintering behavior of refractory materials. A series of (1-x)MgAl2O4-xMg2TiO4 (x = 0, 0.02, 0.04, 0.06, 0.08, and 0.1) spinel solid solutions with a present ration of components were fabricated from light calcined magnesia, reactive alumina and pre-preparation Mg2TiO4. The effect of Mg2TiO4 heterogeneous nucleating agent on the crystalline phase, densification, and microstructure evolution of MgAl2O4–Mg2TiO4 spinel solid solutions was studied. The XRD, XPS, and EDS results showed that Mg2TiO4 entered the lattice of MgAl2O4 to form a spinel solid solution, and the heterovalent substitution process was identified, where Ti4+ and Mg2+ ions of larger radius in the Mg2TiO4 replaced the Al3+ of smaller radius in the MgAl2O4. For the sample at x = 0.08, the spinel solid solutions exhibited the optimized densification with a relative density of 93.3%, an apparent porosity of 1.2%, and a compressive strength of 84.5 MPa. A significant increase in densification was related to the lattice distortion induced by ion size mismatch during the heterovalent substitution, thus accelerating the diffusion rate of Mg2+ and Al3+ ions in the spinelisation state. Moreover, the solid solubility content of Ti4+ in the MgAl2O4–Mg2TiO4 spinel solid solutions had a significant effect on the grain morphologies. The Mg2TiO4 heterogeneous nucleating agent significantly increased the spinelisation rate of MgAl2O4 spinel with negligible effect on densification.

Synthesis of Aluminum Titanate Solid Solution by Solid State Reaction of Fine Commercial Al2o3, Tio2 and Mgo Powders

Synthesis Of Fe-Doping Aluminum Titanate Powders

Effects of (mg1/3nb2/3) Substitution on the Structure and Microwave Dielectric Properties of Sr2TiO4 Ceramics

PREPARATION AND PROPERTIES OF ALUMINUM TITANATE SOLID SOLUTION CERAMICS

Preparation and properties of Al2O3/Al-2(1-0.2)Mg0.2Ti(1+0.2)O5 matrix ceramic composite

Structure ,thermal Expansion and Thermal Stability of Aluminium Titanate Materials

RESEARCH ON SOLID-PHASE SYNTHESIS AND MODIFICATION OF ALUMINUM TITANATE

Sintering behavior and microstructure of (1-x)MgAl2O4-xMg2TiO4 spinel solid solutions prepared by isostructural heterogeneous nucleation

Effect of Adding Cr2O3/Fe2O3 on Aluminum Titanate Properties

Effect of Cr2O3 and Sintering Temperature on the Property of Aluminum Titanate Prepared with Alumina-Titania Slag

Sintering behavior and thermal shock resistance of aluminum titanate (Al2TiO5)-toughened MgO-based ceramics

Effect of Al2O3 and TiO2 Addition Amount on Properties of MgO-based Ceramics by Coprecipitation Method

Synthesis of Al{sub 2}o{sub 3}-Tic and Al{sub 2}o{sub 3}-Tib{sub 2} Composite Powders by Combustion Method

Semi-oxalate synthesis of (1−x)BaTiO3−xM0.5Bi0.5TiO3 (M = Li, Na, K) PTCR materials

Investigation on mechanical and thermal properties of MgAl2O4-Mg2TiO4 solid solutions with spinel-type structure

Densification and microstructural correlation with thermo-mechanical strength of TiO2-doped (Al1-xCrx)2O3 (x=0.1, 0.3) solid solution ceramics

Molten-salt Synthesis of BaTiO3 Powders and Their Atomic-Scale Structural Characterization

The Synthesis of Ultrafine Ba/Sr Titanate Powders

Synthesis of SrTixZr1-xO3 Solution and Thermodynamic Analyze

Effect of Manganese Ions Concentration on the Anatase–rutile Phase Transformation of TiO2 Films

Preparation of transparent MgAlON ceramics with tunable compositions