Abstract:With the continued device scaling and the introduction of new device structures, MOSFET reliability phenomena arising from the hot carrier injection (HCI) stress have received extensive attention from both the academia and the industry community. In this work, the degradations of ultra-scaled silicon on insulator (SOI) MOSFETs under the HCI stress are investigated on devices of different gate lengths (L=30-150 nm). Our experimental data demonstrate that the time evolutions of the threshold voltage change (Vth) under the HCI stress for different gate length devices are the same, and the magnitude of Vth reduces for the shorter devices. The degradation of the device under the HCI stress should be due to both the channel hot carrier (CHC) effect and the bias temperature instability (BTI) effect. The distribution and magnitude of the electric field along the MOSFET's channel are analyzed. It is confirmed that besides the well-known CHC effect in the depletion region close to the drain side, a strong BTI effect co-exists in the channel close to the source side. This degradation mechanism is different from the conventional HCI stress. With the gate length decreasing, the contribution of the aforementioned BTI effect becomes larger, and it dominates in the degradation. One feature of the BTI effects is that the corresponding degradation is small when the gate length is short. This is consistent with our experimental result that the change of Vth is small for the device of short gate length under the accelerated HCI stress. The time evolution of Vth can be described by the equation Vth=A•tn, where A is a constant, t is the stress time, and n is the power law exponent obtained by the curve fitting. In this study, the power law exponent n of pMOSFET is larger than that of nMOSFET. This experimental fact can lead to the point that the BTI effect exists during the HCI stress because the BTI effect in ultra-scaled pMOSFETs is more significant than that in nMOSFETs. The stress-recover experiments of the HCI stress on MOSFTTs show larger recovery in device of shorter gate length. It is found that the ratio of the recovery to the total degradation in the 30 nm gate-length device is almost twice as large as that in the 150 nm device. The degradation from the CHC effect has no recovery, and the larger recovery in the shorter-channel device implies the larger component of the BTI degradation. Another intriguing fact is that our experimental result on SOI MOSFET is inconsistent with the recently reported result on FinFET. We argue that the reported stronger HCI degradation in FinFET may not be ascribed only to the stronger electric field in the shorter channel, but also to the fact that the FinFET' channel is three-dimensionally surrounded by the gate dielectric. This kind of three-dimensional structure significantly increases the chance for electrons or holes to be injected into the dielectric layer. Therefore the HCI reliability of planar SOI MOSFETs may be better than that of FinFETs at the same level of gate length. In conclusion, the BTI effect is an important source of the degradation during the HCI stress in ultra-short-channel device, and it is no more negligible in analyzing the underlying physical mechanism.

Study on the Degradation Induced by Donor Interface State in Deep-Sub-micron Grooved-Gate P-channel MOSFET’s

Performance Analysis of Ultra-thin-Body, Double-Gate pMOSFETs at 5 nm Technology Node

Strain Optimization in Silicon P-Type Double-Gate MOSFET at 7nm Channel Length

Deep Insight into Channel Engineering of Sub-3 Nm-Node P-Type Nanosheet Transistors with a Quantum Transport Model

Gate Length Dependence of Hot Carrier Injection Degradation in Short Channel Silicon on Insulator Planar Mosfet

Influence of Different Device Structures on the Degradation for Trench-Gate SiC MOSFETs: Taking Avalanche Stress as an Example

Hot carrier degradation behavior in SOI dynamic-threshold-voltage nMOSFET’s (n-DTMOSFET) measured by gated-diode configuration

A physical based model to predict performance degradation of FinFET accounting for interface state distribution effect due to hot carrier injection

Hot-Carrier-Induced Defects Distribution And Coupling Effect Of The Front And Back Interface Degradation In Soi Nmosfet'S Operating In A Bi-Mos Hybrid Mode

Carrier injection induced degradation of nitrogen passivated SiC–SiO2 interface simulated by time-dependent density functional theory

Evaulation the Degradation in Nmosfets with HfO2 Gate Dielectric and Interfacial Layer by 3D Kinetic Monte-Carlo Method

Characterization and Modelling of Hot Carrier Degradation in Pfets under Vd>Vg Condition for Sub-20Nm DRAM Technologies.

Impacts of gate line edge roughness on sub 100nm MOSFETs

Investigation of Inrush Current Induced Trench Gate Degradation inside SiC MOSFET by New Fowler- Nordheim Localization Methodology

Impact of Substrate Injected Hot Electrons on Hot Carrier Degradation in a 180-Nm NMOSFET

Investigation on the Degradation Mechanism for SiC Power MOSFETs Under Repetitive Switching Stress

Analytic subthreshold slope model for deep-submicrometer fully depleted SOI MOSFET's

A Comprehensive Analysis of Unclamped-Inductive-Switching-Induced Electrical Parameter Degradations and Optimizations for 4H-SiC Trench Metal-Oxide-Semiconductor Field-Effect Transistor Structures

Study on The Degradations Produced by Different P-base Diffusion Temperatures on SGT MOSFET With Approximate Threshold Voltage

Modeling of Degradation Caused by Channel Hot Carrier and Negative Bias Temperature Instability Effects in P-Mosfets

Correlating device behaviors with semiconductor lattice damage at MOS interface by comparing plasma-etching and regrown recessed-gate Al2O3/GaN MOS-FETs