Abstract:With the continued device scaling and the introduction of new device structures, MOSFET reliability phenomena arising from the hot carrier injection (HCI) stress have received extensive attention from both the academia and the industry community. In this work, the degradations of ultra-scaled silicon on insulator (SOI) MOSFETs under the HCI stress are investigated on devices of different gate lengths (L=30-150 nm). Our experimental data demonstrate that the time evolutions of the threshold voltage change (Vth) under the HCI stress for different gate length devices are the same, and the magnitude of Vth reduces for the shorter devices. The degradation of the device under the HCI stress should be due to both the channel hot carrier (CHC) effect and the bias temperature instability (BTI) effect. The distribution and magnitude of the electric field along the MOSFET's channel are analyzed. It is confirmed that besides the well-known CHC effect in the depletion region close to the drain side, a strong BTI effect co-exists in the channel close to the source side. This degradation mechanism is different from the conventional HCI stress. With the gate length decreasing, the contribution of the aforementioned BTI effect becomes larger, and it dominates in the degradation. One feature of the BTI effects is that the corresponding degradation is small when the gate length is short. This is consistent with our experimental result that the change of Vth is small for the device of short gate length under the accelerated HCI stress. The time evolution of Vth can be described by the equation Vth=A•tn, where A is a constant, t is the stress time, and n is the power law exponent obtained by the curve fitting. In this study, the power law exponent n of pMOSFET is larger than that of nMOSFET. This experimental fact can lead to the point that the BTI effect exists during the HCI stress because the BTI effect in ultra-scaled pMOSFETs is more significant than that in nMOSFETs. The stress-recover experiments of the HCI stress on MOSFTTs show larger recovery in device of shorter gate length. It is found that the ratio of the recovery to the total degradation in the 30 nm gate-length device is almost twice as large as that in the 150 nm device. The degradation from the CHC effect has no recovery, and the larger recovery in the shorter-channel device implies the larger component of the BTI degradation. Another intriguing fact is that our experimental result on SOI MOSFET is inconsistent with the recently reported result on FinFET. We argue that the reported stronger HCI degradation in FinFET may not be ascribed only to the stronger electric field in the shorter channel, but also to the fact that the FinFET' channel is three-dimensionally surrounded by the gate dielectric. This kind of three-dimensional structure significantly increases the chance for electrons or holes to be injected into the dielectric layer. Therefore the HCI reliability of planar SOI MOSFETs may be better than that of FinFETs at the same level of gate length. In conclusion, the BTI effect is an important source of the degradation during the HCI stress in ultra-short-channel device, and it is no more negligible in analyzing the underlying physical mechanism.

Carrier injection induced degradation of nitrogen passivated SiC–SiO2 interface simulated by time-dependent density functional theory

Hot-carrier-induced On-Resistance Degradation of Step Gate Oxide NLDMOS

Gate Length Dependence of Hot Carrier Injection Degradation in Short Channel Silicon on Insulator Planar Mosfet

Hot carrier degradation behavior in SOI dynamic-threshold-voltage nMOSFET’s (n-DTMOSFET) measured by gated-diode configuration

Investigation of Inrush Current Induced Trench Gate Degradation inside SiC MOSFET by New Fowler- Nordheim Localization Methodology

Atomistic Mechanism of 4 H - SiC/SiO2 Interface Carrier-Trapping Effects on Breakdown-Voltage Degradation in Power Devices

A Decrease in TDDB Lifetime of Commercial SiC Power MOSFETs under Repetitive Unclamped Inductive Switching Stresses

Electronically Induced Defect Creation at Semiconductor/oxide Interface Revealed by Time-Dependent Density Functional Theory

Physical Principles of Self-Consistent Simulation of the Generation of Interface States and the Transport of Hot Charge Carriers in Field-Effect Transistors Based on Metal–Oxide–Semiconductor Structures

A Multiscale Simulation on Aluminum Ion Implantation-Induced Defects in 4H-SiC MOSFETs

Investigation On Degradation Mechanism And Optimization For Sic Power Mosfets Under Long-Term Short-Circuit Stress

A Comprehensive Analysis of Unclamped-Inductive-Switching-Induced Electrical Parameter Degradations and Optimizations for 4H-SiC Trench Metal-Oxide-Semiconductor Field-Effect Transistor Structures

Influence of Different Device Structures on the Degradation for Trench-Gate SiC MOSFETs: Taking Avalanche Stress as an Example

Modeling of Charge-to-Breakdown with an Electron Trapping Model for Analysis of Thermal Gate Oxide Failure Mechanism in SiC Power MOSFETs

Atomistic Mechanism of 4 H - Si C / Si O 2 Interface Carrier-Trapping Effects on Breakdown-Voltage Degradation in Power Devices

Ionization Radiation-Induced Reliability Degradation of SiC Power MOSFET

Investigations on the Degradations of Double-Trench SiC Power MOSFETs under Repetitive Avalanche Stress

Analysis of Displacement Damage Induced by Silicon-Ion Irradiation in SiC MOSFETs

Investigation on the Degradation Mechanism for SiC Power MOSFETs Under Repetitive Switching Stress

Degradation of 650 V SiC double-trench MOSFETs under repetitive overcurrent switching stress

The Effect of Diluted N2O Annealing Time on Gate Dielectric Reliability of SiC Metal-Oxide Semiconductor Capacitors and Characterization of Performance on SiC Metal-Oxide Semiconductor Field Effect Transistor