Abstract:With the continued device scaling and the introduction of new device structures, MOSFET reliability phenomena arising from the hot carrier injection (HCI) stress have received extensive attention from both the academia and the industry community. In this work, the degradations of ultra-scaled silicon on insulator (SOI) MOSFETs under the HCI stress are investigated on devices of different gate lengths (L=30-150 nm). Our experimental data demonstrate that the time evolutions of the threshold voltage change (Vth) under the HCI stress for different gate length devices are the same, and the magnitude of Vth reduces for the shorter devices. The degradation of the device under the HCI stress should be due to both the channel hot carrier (CHC) effect and the bias temperature instability (BTI) effect. The distribution and magnitude of the electric field along the MOSFET's channel are analyzed. It is confirmed that besides the well-known CHC effect in the depletion region close to the drain side, a strong BTI effect co-exists in the channel close to the source side. This degradation mechanism is different from the conventional HCI stress. With the gate length decreasing, the contribution of the aforementioned BTI effect becomes larger, and it dominates in the degradation. One feature of the BTI effects is that the corresponding degradation is small when the gate length is short. This is consistent with our experimental result that the change of Vth is small for the device of short gate length under the accelerated HCI stress. The time evolution of Vth can be described by the equation Vth=A•tn, where A is a constant, t is the stress time, and n is the power law exponent obtained by the curve fitting. In this study, the power law exponent n of pMOSFET is larger than that of nMOSFET. This experimental fact can lead to the point that the BTI effect exists during the HCI stress because the BTI effect in ultra-scaled pMOSFETs is more significant than that in nMOSFETs. The stress-recover experiments of the HCI stress on MOSFTTs show larger recovery in device of shorter gate length. It is found that the ratio of the recovery to the total degradation in the 30 nm gate-length device is almost twice as large as that in the 150 nm device. The degradation from the CHC effect has no recovery, and the larger recovery in the shorter-channel device implies the larger component of the BTI degradation. Another intriguing fact is that our experimental result on SOI MOSFET is inconsistent with the recently reported result on FinFET. We argue that the reported stronger HCI degradation in FinFET may not be ascribed only to the stronger electric field in the shorter channel, but also to the fact that the FinFET' channel is three-dimensionally surrounded by the gate dielectric. This kind of three-dimensional structure significantly increases the chance for electrons or holes to be injected into the dielectric layer. Therefore the HCI reliability of planar SOI MOSFETs may be better than that of FinFETs at the same level of gate length. In conclusion, the BTI effect is an important source of the degradation during the HCI stress in ultra-short-channel device, and it is no more negligible in analyzing the underlying physical mechanism.

Barrier Height Change in Very Thin Sio2 Films Caused by Charge Injection

Gate-Induced Image Force Barrier Lowering in Schottky Barrier FETs

Gate Length Dependence of Hot Carrier Injection Degradation in Short Channel Silicon on Insulator Planar Mosfet

Gate tunneling currents in ultrathin oxide metal–oxide–silicon transistors

Fringe-Induced Barrier Lowering (fibl) Included Sub-Threshold Swing Model for Double-Gate Mosfets

Threshold Voltage Variation in SOI Schottky-Barrier MOSFETs

Charge trapping effects in gate oxide under Fowler-Nordheim electron injection at temperature of 77K

An Unified Model to Characterize the Strong Inversion High-Frequency Capacitance in Thin Oxide MOS Structures under Fowler-Nordheim Tunneling Injection Condition

Dynamics Of Surface Charge Region Of Thin Insulator N-Type Mos Structures

Experimental Evidence of Inversion-Layer Mobility Lowering in Ultrathin Gate Oxide Metal-Oxide-Semiconductor Field-Effect-Transistors with Direct Tunneling Current

Gate-Controlled electron injection in tunneling contact IGZO TFTs

Insertion Of An Ultrathin Al2o3 Interfacial Layer For Schottky Barrier Height Reduction In Ws2 Field-Effect Transistors

Role of Si Implantation in Control of Underlap Length in Schottky-barrier Source/drain MOSFETs on Ultrathin Body SOI

Comprehensive Stress Effect of Thin Coatings and Silicon-Carbon Lattice Mismatch on Nano-Scaled Transistors with Protruding Poly Gate

Charge trapping analysis in sputtered BixSe1-x based accumulation-mode FETs

Charge Trapping in Thin Gate Oxides of Nmosfets at 77 K During Uniform Fowler-Nordheim Electron Injection

Quantum-mechanical modeling of electron tunneling current from the inversion layer of ultra-thin-oxide nMOSFET's

Characterization of tunneling current in ultra-thin gate oxide

Effects of gate material on Fowler-Nordheim stress induced thin silicon dioxide degradation under negative gate bias

Edge hole direct tunneling leakage in ultrathin gate oxide p-channel MOSFETs

Direct Tunneling Current Model for MOS Devices with Ultra-Thin Gate Oxide Including Quantization Effect and Polysilicon Depletion Effect