Abstract:Thin‐film rechargeable lithium batteries with amorphous and crystalline LiCoO2 cathodes were investigated. The lithium cobalt oxide films were deposited by radio‐frequency (RF) magnetron sputtering of an LiCoO2 target in a 3:1 Ar/ O2 mixture gas. From proton‐induced γ‐ray emission analysis (PIGE) and Rutherford backscattering spectrometry (RBS), the average composition of these films was determined to be Li1.15CoO2.16 or, within experimental uncertainty, LiCoO2+0.08 Li2O . The x‐ray powder diffraction patterns of films annealed in air at 500 to 700°C were consistent with the regular hexagonal structure observed for crystalline LiCoO2 . The discharge curves of the cells with amorphous LiCoO2 cathodes showed no obvious structural transition between 4.2 and 2.0 V, while the discharge curves of the cells with polycrystalline cathodes were consistent with a two‐phase potential plateau at ∼3.9 V with a relatively large capacity. Two lower capacity plateaus were observed at ∼4.2 and 4.1 V with the 600 and 700°C annealed cathodes; the −dq/dV peaks were broader and weaker for the 600°C annealed cathodes and were not present at all with the 500°C annealed films. The chemical diffusion coefficients of Li+ in the cathodes obtained from ac impedance measurements at cell potentials of ∼4V ranged from ∼10−12 cm2/s for the as‐deposited amorphous cathodes to ∼10−9 cm2/s for the films annealed at 700°C. The capacity loss on extended cycling of the thin‐film cells varied with the crystallinity and thickness of the cathodes and with temperature. With the highly crystalline, 700°C annealed material, losses on cycling between 4.2 and 3.8 V at 25°C ranged from 0.0001%/cycle (>104 cycles) to 0.002%/cycle for cells with cathodes from 0.05 to 0.5 μm thick.

An amorphous LiCo1/3Mn1/3Ni1/3O2 thin film deposited on NASICON-type electrolyte for all-solid-state Li-ion batteries

Amorphous LiCoO2 Thin Films on Li1+x+yAlxTi2−xSiyP3−yO12 Prepared by Radio Frequency Magnetron Sputtering for All-Solid-state Li-ion Batteries

Electrochemical Performance of All-Solid-state Li Batteries Based LiMn0.5Ni0.5O2 Cathode and NASICON-type Electrolyte

Cathode Materials of Li_xCo_(0.8)Ni_(0.2)O_2 for Lithium-ion Battery

All-Solid-State Thin Film Lithium Batteries With Licoo2 Cathodes

Li-ion Diffusion Kinetics in LiCoPO4 Thin Films Deposited on NASICON-type Glass Ceramic Electrolytes by Magnetron Sputtering

Reduction of charge-transfer resistance at the solid electrolyte – electrode interface by pulsed laser deposition of films from a crystalline Li 2 PO 2 N source

Physical and Electrochemical Characterization of LiCo0.8M0.2O2 (m=ni,zr) Cathode Films for All-solid-state Rechargeable Thin-film Lithium Batteries

Li-ion Transport in All-Solid-state Lithium Batteries with LiCoO2 Using NASICON-type Glass Ceramic Electrolytes

Li metal coated with Li3PO4 film via atomic layer deposition as battery anode

Layered Li(Ni[sub 1/4]mn[sub 1/2]co[sub 13])o[sub 2] As Cathode Material for All-Solid-State Thin-Film Rechargeable Lithium-Ion Batteries

Controllable crystalline preferred orientation in Li-Co-Ni-Mn oxide cathode thin films for all-solid-state lithium batteries

Characterization of Thin‐Film Rechargeable Lithium Batteries with Lithium Cobalt Oxide Cathodes

A nanocrystalline Co3O4 thin film electrode for Li-ion batteries

Isomeric Li–La–Zr–O Amorphous–Crystalline Composite Thin-Film Electrolytes for All-Solid-State Lithium Batteries

A Nanocrystalline Nio Thin-Film Electrode Prepared by Pulsed Laser Ablation for Li-Ion Batteries

Simple Solid-State Method for Synthesis of Li[Li 0.20 Mn 0.534 Ni 0.133 Co 0.133 ]O 2 Cathode Material with Improved Electrochemical Performance in Lithium-Ion Batteries

Three-dimensional porous amorphous SnO2 thin films as anodes for Li-ion batteries

Nanostructured NiSi thin films as a new anode material for lithium ion batteries

Ionic conductivity properties of amorphous Li–La–Zr–O solid electrolyte for thin film batteries

Studies on lithium phosphorous oxynitride electrolyte thin films and a new all-solid-state thin film lithium battery