Abstract:The effect of different type of heteropolyacid/Zr-MCM-41 catalysts on the catalytic amination of glycerol with dimethylamine to produce Dimethylamino-3-propanal was researched. Under the premise of their respective optimum loading amount, the specific surface area, pore volume and pore size of the H6P2W18O62/Zr-MCM-41(Cat-2) were higher than those of the H3PW12O40/Zr-MCM-41(Cat-1). Cat-1 exhibited more total acidity than that of Cat-2, which resulted in the higher glycerol conversion of Cat-1 at the beginning of the reaction, but the coke deposited on Cat-1 was more than that of Cat-2. The amount of Bronsted acid sites and ratio of B/(B + L) on Cat-2 were higher than that of Cat-1. Therefore, the catalytic stability, selectivity and yield of Dimethylamino-3-propanal of Cat-2 were higher than those of Cat-1, which proved that the Bronsted acid sites are good for the catalytic amination of glycerol with dimethylamine to produce Dimethylamino-3-propanal. The leaching ratio of Cat-2 is slightly more than that of Cat-1, because H6P2W18O62 is more hydrophilic than H3PW12O40. However, the stability of Cat-2 is higher than that of Cat-1, therefore, the main reason for deactivation of catalyst is the formation of carbon deposit during this reaction. And the reaction pathway of catalytic amination of glycerol with dimethylamine was proposed. Furthermore, the reaction temperature, GHSV and the molar ratio of dimethylamine/glycerol were optimized on Cat-2 catalyst. Under the optimum reaction conditions: 300 degrees C, H6P2W18O62 loading of 20 wt%, GHSV of 3 h(-1), glycerol aqueous concentration of 10 wt%, dimethylamine aqueous concentration of 30 wt%, molar ratio of dimethylamine/glycerol of 2.5, the glycerol conversion, selectivity and yield of Dimethylamino-3-propanal were 95.6%, 80.8% and 77.2%, respectively.

Catalytic Hydrogenation of N, N-dimethyl Laurylamide to Produce N, N-dimethyl Laurylamine

Hydrogenation of M-Dinitrobenzene to M-Phenylenediamine over La2o3-Promoted Ni/Sio2 Catalysts

Study on the Ni Supported Catalysts Used for Hydrogenation of IPN to Produce MXDA

Synthesis of m-phenylenediamine from m-dinitrobenzene over silica-supported nickel catalyst

Synthesis of N, N-dimethyl-n-butylamine with Tubular Reactor

Synthesis of N , N -dimethyldodecylamine by the catalytic hydrogenation of N , N -dimethyldodecylamide

Hydrogenation of Levulinic Acid over Nickel Catalysts Supported on Aluminum Oxide to Prepare Γ-Valerolactone

Catalytic Synthesis of N,N,N',N'-tetramethylethylenediamine in Fixed-Bed Reactor

Catalytic Hydrogenation for the Green Synthesis of N-(3-Amino-4-methoxyphenyi)acetamide

Optimization of Catalytic Hydrogenation L-Alanine to L-Alaninol

Catalytic Hydrogenation of Levulinic Acid to Gamma-Valerolactone over Ni/ZrO2

Effects of the Preparation Methods on the Properties of Ni-La2o3-Sio2 Catalysts for M-Dinitrobenzene Hydrogenation

Synthesis of Propionitrile by Acrylonitrile Hydrogenation over the Ni Catalyst in the Gas-solid Phase

Sustainable Efficient Synthesis of Pyrrolidones from Levulinic Acid over Pd/C Catalyst

Preparation of Hydrothermally Stable, Basic, and Highly Active Nano Nickel Catalysts for the Hydrodeoxygenation of N,N-dimethylformamide

The effect of surface acidic and basic properties on the hydrogenation of lauronitrile over the supported nickel catalysts

Catalytic Amination of Glycerol with Dimethylamine over Different Type Ofheteropolyacid/zr-Mcm-41 Catalysts

A novel two-step process for the synthesis of hexamethylenediamine from 6-hydroxyhexanenitrile derived from ε-caprolactone

Gas-phase hydrogenation of adiponitrile with high selectivity to primary amine over supported Ni-B amorphous catalysts

Effects of preparation conditions for Ni/γ-Al2O3 catalyst on saturated hydrogenation of naphthalene

An Efficient and Reusable Bimetallic Ni3Fe NPs@C Catalyst for Selective Hydrogenation of Biomass-Derived Levulinic Acid to Γ-Valerolactone