Abstract:Low-temperature-initiated cracking technology has significant potential to develop new hydrocarbon pyrolysis with better atomic economy and higher yields of light olefins. The impacts of three representative initiators, triethylamine (TEA), nitromethane (NM), and di-tert-butyl peroxide (DTBP), were compared. Sufficiently detailed co-cracking reaction networks of three initiators with n-hexane were obtained through an automatic reaction network generator RMG, and the corresponding steam cracking tubular reactor simulation was performed. The results showed that the initiator with a lower cracking temperature brought about a more noticeable decrease in the cracking temperature of n-hexane. Both TEA and NM increased the carbon atom conversion from n-hexane to ethylene and propylene, especially propylene. NM was more significant, while DTBP was almost ineffective. Through kinetic parameter analysis, it was found that the temperature dependence of the key reaction caused different initiator performance. NM completely cracked at an appropriate temperature where the rate constants of the hydrogen abstraction and ethylene generation had reached a high level, and the released free radicals were effective. Visual reaction network analysis revealed that NM had a strong ability to release free radicals, and these free radicals significantly adjusted the competitive reaction path to produce ethylene and propylene, resulting in the most obvious effect on improving the conversion of n-hexane and the yield of propylene. The action laws of NM described above under hydrocarbon pyrolysis conditions indicate that NM may be the most suitable initiator for low-temperature-initiated cracking of hydrocarbons among these three initiator types.

Study on the technology of thermal cracking of paraffin to alpha olefins

Preparation of Α-Olefins Through the Steam Cracking Process of Wax from Coal Liquefaction

Low-Temperature-Initiated Cracking of Hydrocarbons to Produce Olefins: Simulation and Comparison of Different Initiators

Study on hydroformylation synthesis of higher alcohol with olefins from paraffin cracking

Study on Synthesis and Application of Poly Alpha Olefins Based on Alpha Olefins Produced from Coal Liquefied Wax Cracking Process

Synthesis of Poly Alpha Olefins Using Alpha Olefins Obtained from the Steam Cracking Process of Coal Liquefaction Wax

Effect of Normal Paraffin Content on Ethylene Yield and Feedstock Allocation of Ethylene Pyrolysis Process

SEPARATING GROUP COMPOSITIONS IN NAPHTHA TO IMPROVE OLEFIN YIELDS OF STEAM CRACKING PROCESS

STEAM CRACKING PERFORMANCE OF FEEDSTOCKS RICH IN NORMAL PARAFFINS GATHERED BY ADSORPTION PROCESS

Study on the influence of low-carbon alcohol on non-hydrodewaxing reaction of hydrocracking tail oil

Separating Group Compositions in Naphtha by Adsorption and Solvent Extraction to Improve Olefin Yields of Steam Cracking Process

Optimizing Naphtha Utilization Based on Molecular Scale Management

Separation and Optimizing Utilization of Normal Paraffin in the Condensate Oil

STUDY ON NON-CATALYTIC OXIDATION OF PARAFFIN WAX AND MICROCRYSTILLINE WAX

Advances in Fischer-Tropsch wax hydrocracking process

Study on optimized culture of microbial strains and their ability in wax removal and viscosity reduction of paraffin-based crude oil

Commercial experiment of synthesis of 8b and 20# aviation engine oils

Recombination of naphtha for increasing the yields of cracking olefins and aromatics by extraction technique

Multicycle Investigation of Normal Paraffin Separation from Naphtha to Improve Olefin and Aromatic Feed

Recovery of Paraffin from the Filter Cake Used for Paraffin Decoloration in the Fischer-Tropsch Synthetic Process

Dual function intensified cracking of waste engine oil to produce alkane-rich oil: Study on the synergistic effect of Fe-Co/MCM41 catalyst and microwave