Abstract:Nowadays, the zero liquid discharge of flue gas desulfurization (FGD) wastewater from coal-fired units has attracted the attention of all countries in the world. The pretreatment methods generally have the problems of high operation cost, small treatment capacity, and poor flexibility. However, the membrane method can avoid the above problems. In the current research, it has not been found that someone directly uses submerged ultrafiltration to pretreat FGD wastewater. Therefore, this paper innovatively proposed to directly use ceramic ultrafiltration membrane to treat FGD wastewater, which can ensure effluent quality and improve the flexibility of the pretreatment system. In this paper, the performance of submerged ultrafiltration membrane for the filtration of FGD wastewater from a power plant was studied to optimize the filtration performance and improve the effluent quality. The effects of operating parameters such as membrane permeate flux, aeration rate and filtration/backwashing time combination on the membrane performance were studied. The results showed that when the filtration/backwashing time combination was 15 min/30 s, with the increased in permeate flux from 55 L/(m2·h) to 100 L/(m2·h), the steady transmembrane pressure (TMP) increased from 39 kPa to 70 kPa, and the fouling rate increased significantly from 4.5 kPa/h to 7.3 kPa/h; When the aeration rate increased from 10 m3/(m2·h) to 30 m3/(m2·h), the membrane pollution was much reduced. Excessive aeration rate cannot further alleviate the membrane pollution, but also brought greater energy consumption; Increasing backwashing time can effectively inhibit the formation of gel layer on the surface of the membrane and prolong the initial stage of low-pressure operation; The rejection of suspended solids (SS) and turbidity of the equipment studied in this paper can reach more than 99% under various working conditions, which can satisfy the water quality requirements of the subsequent steps. The submerged ultrafiltration membrane was suitable for the pretreatment of FGD wastewater because it can ensure the quality of permeate under the premise of long-term operation.

Technical Retrofitting of Water Demineralizing System in Huangpu Power Plant

Applying Water Treatment Technique on Water Hydraulic System

TEST STUDY ON CONPREHENSIVE RETROFIT OF BOILER’S HEAT RECOVERY SURFACE

Demonstration Operation of Integrated Membrane System for Treatment of Source Water from Qiantang River during Tidal Periods

Coal-fired power plant desulfurization wastewater dechlorination treatment device

TECHNOLOGY OF RETROFITTING DESIGNED 220 T/h OIL-FIRED BOILER INTO COAL-WATER-SLURRY FIRED ONE AND APPLICATION THEREOF

MODEL TEST AND NUMERICAL ANALYSIS OF FLOW FIELD IN SCR DENITRIFICATION SYSTEM IN SECOND-PHASE PROJECT OF SANHE POWER PLANT

Integrated process of nanofiltration for treating tidal salty water from Qiantang River

Simulation and Operational Optimization of RO Based Desalination for Coal-Fired Power Plants’ Wastewater

Evaluation on Operation Stability of a Flue Gas Desulfurization System After Ultra-low Emission Retrofit of the Coal-fired Unit

The reliability evaluation of reclaimed water reused in power plant project

Advanced Treatment of Wastewater from an Iron and Steel Enterprise by A Constructed Wetland/Ultrafiltration/Reverse Osmosis Process

Design and Operation of Upgrading and Retrofitting Project of A2/C Oxidation Ditch Process

Discussion on the technical route of water pollution prevention and comprehensive utilization in thermal power plant

PROBLEMS AND COUNTERMEASURES IS TRANSFORM OF 150MW RECYCLE SEMI-DRY DESULFRIZATION PROCESS

[Successful pregnancy outcome in a patient with acute renal failure superimposed on chronic renal failure treated with repeated hemodialysis].

Optimization of Disinfection Technology and Its Application in Water Treatment Plant

Operating experience of CFB semi-dry FGD with novel humidification technology in China

Application of Electrodeionization Technology in Treatment of Boiler Make-up Water of Thermal Power Plant

SEVERAL PROBLEMS'S ANALYSIS OF RECYCLE SEMIDRY DESULFRIZATION SYSTEM IN COAL-FIRED POWER PLANTS

Application of Submerged Ultrafiltration in Pretreatment of Flue Gas Desulfurization Wastewater