Abstract:The hot strip method, as one typical transient method, is widely used to measure the effective thermal conductivity of thermal insulation materials at various temperatures. Since the test theory is based on solving the energy equation via heat conduction, the test result will be questionable when measuring thermal insulation materials, such as silica aerogel and photovoltaic glazing, in which the participating thermal radiation is a dominant heat transfer mode at high temperature. In this study, numerical investigation is employed to reveal the measurement reliability of hot strip method when applied to translucent thermal insulation materials. By reproducing the dynamic conduction-radiation coupled heat transfer process within the translucent materials numerically, the effective thermal conductivity of translucent materials with varying extinction coefficients are obtained at various temperatures. Comparisons are made for the effective thermal conductivity of translucent materials determined by the hot strip method, one-dimensional steady state method, transient plane source method and Rosseland model. Large discrepancies are found among the effective thermal conductivity determined by different methods for translucent materials with low extinction coefficient. The thermal conductivity obtained from the hot strip method is overestimated at elevated temperature when compared with that from one-dimensional steady state method. In order to measure the effective thermal conductivity of translucent materials accurately, the effect of thermal radiation should be considered for different transient methods.

Comparing Different Methods of Measuring Thermal Conductivity of Good Conductor

Thermal Characterization of Microscale Conductive and Nonconductive Wires Using Transient Electrothermal Technique

Measuring thermal conductivity of poor conductor by stable-state comparative method

SUPPLEMENTARY EXPERIMENT INVESTIGATION ON THERMAL CONDUCTIVITY MEASURED BY STEADY-STATE PLATE METHOD

The Principle To Measure Thermal Conductivity By A New Thermal Probe Method

Equivalence of the Equilibrium and the Nonequilibrium Molecular Dynamics Methods for Thermal Conductivity Calculations: from Bulk to Nanowire Silicon

Contactless Measurement Of Electrical Conductivity Of Si Wafers Independent Of Wafer Thickness

Identification of Temperature-Dependent Thermal Conductivity and Experimental Verification

Determining The Wiedemann-Franz Ratio From The Thermal Hall Conductivity: Application To Cu And Yba2cu3o6.95

Determination of Thermal Properties of Metals by Using of Periodic Heat Flow Method

A high-precision method to measure thermal conductivity of solids using reversible heat flux

Short Hot Wire Technique for Measuring Thermal Conductivity and Thermal Diffusivity of Various Materials

Precise Determination of the Thermal Conductivity of the Thermal Insulating Metal Material

Simultaneous measurements of the specific heat and thermal conductivity of suspended thin samples by transient electrothermal method.

Influence of Participating Radiation on Measuring Thermal Conductivity of Translucent Thermal Insulation Materials with Hot Strip Method

A Steady-State Short-Hot-Wire Method For Measurement Of Thermal Conductivity Of A Single Carbon Fiber

Short-Hot-Wire Method for the Measurement of the Thermal Conductivity of A Fine Fibre

MEASUREMENT OF THERMAL CONDUCTIVITIES OF NANOFLUIDS

Long Short Hot-Probe Method for Determining Thermophysical Properties

Research on the 3ω method for thermal conductivity measurements at low temperatures

Methods for Measuring Thermal Conductivity of Two-Dimensional Materials: A Review