Abstract:Zinc oxide (ZnO) films with thicknesses from (9.1 +/- 0.7) to (145 +/- 7) nm were deposited on silicon substrates by ion-assisted electron beam evaporation (EBE), and transformed to a highly (110)-oriented non-polar phase through thermal treatment at temperatures of 300, 500, and 700 degrees C. The structural, morphological and optical properties of the ZnO thin films were systematically characterized using transmission electron microscopy (TEM), X-ray diffraction (XRD), atomic force microscopy (AFM), spectroscopic ellipsometry (SE), and photoluminescence (PL). The XRD and AFM results illustrate that the deposited ZnO films evolved from an X-ray amorphous structure to the polycrystalline hexagonal wurtzite structure with increasing thickness and experienced a crystallographic plane improvement from (102) to the (110) non-polar phase during annealing. The dielectric functions of the whole layer are mainly affected by the dielectric responses near the surface of ZnO nanocrystals and show an upward trend with nanocrystal growth, induced by thickness and annealing temperature. The optical band gaps were also investigated and correlated with the structural properties. In the PL spectra, a strong ultraviolet luminescence (UVL) band and a weak visible green luminescence (GL) band were observed. The intensity ratio of UVL and GL-associated with crystal quality-agrees with the results acquired from other measurements. The two determinants for highly (110)-oriented non-polar ZnO films are the suppression of growth in the (002) direction by ion bombardment and the promotion of the (110) plane induced by diffusion energy during annealing. (C) 2017 Elsevier B.V. All rights reserved.

Effects of the electrochemical deposition conditions on the properties of ZnO polycrystalline thin film

Effect of Nucleation and Growth Kinetics on the Electrical and Optical Properties of Undoped ZnO Films

The growth of nanoscale ZnO films by pulsed-spray evaporation chemical vapor deposition and their structural, electric and optical properties

Effect of Electrodeposition Time on Microstructure, Wettability and Optical Properties of ZnO Nanorod Arrays

Effects of Electrodeposition Electrolyte Concentration on Microstructure, Optical Properties and Wettability of ZnO Nanorods

Effect of Solution Concentrations on Crystal Structure, Surface Topographies and Photoluminescence Properties of ZnO Thin Films

Electrochemical Deposition and Characterization of Wide Band Semiconductor ZnO Thin Film

Effect of solution concentration on surface morphology, optical properties and solar light response of ZnO thin films

Deposition and Characterization of AZO Thin Films on Flexible Glass Substrates Using DC Magnetron Sputtering Technique

The Effects of Oxygen Partial Pressure and Substrate Temperature on the Structural and Optical Properties of Zno Films

Structural, optical and electrical properties of ZnO thin films prepared by reactive deposition

Structural and Optical Properties of Electrodeposited ZnO Thin Films

Microstructure and Electrical Properties of Al-doped ZnO Thin Films

Effects of DC Sputtering Power on the Properties of AZO Films Deposited at Room Temperature for CIGS Photovoltaics

Thermal annealing effect on optical properties of electrodeposited ZnO thin films

Physical and Optical Properties of ZnO Thin Films Grown by DC Sputtering Deposition

Deposition and Characterization of Sputtered ZnO Films

Annealing effect on optical properties of ZnO films fabricated by cathodic electrodeposition

Influence of Sputtering Power on Properties of ZnO Thin Films Fabricated by RF Sputtering in Room Temperature

Influences of Substrate and Annealing on the Structural and Optical Properties and Photoluminescence of Nanocrystalline Zno Films Prepared by Plasma Assisted Pulsed Laser Deposition

Structural and Optical Properties of Highly (110)-Oriented Non-Polar ZnO Evaporated Films on Si Substrates