Abstract:The inverter-fed motor is a key component of environmental-friendly hybrid cars, high-speed trains, and other industrial applications. After the widespread use of inverter-fed motors, the repetitive impulse surges from inverters were found to cause new insulation problems in inverter-fed motors that were linked to premature insulation failure. The partial discharge (PD) induced by the overvoltage inner stator windings was found to be the root cause of insulation reliability problems. To mitigate this problem, PD detection and life testing at repetitive square voltages should be performed on new types of insulation models and entire motor insulation systems. The obtained partial discharge inception voltage (PDIV) and lifetime of insulation in the tests can be used to evaluate the insulation status of inverter-fed motor insulation systems and thus to improve the insulation designs. At AC voltage conditions, the voltage frequency can significantly affect PD activity. At repetitive square voltage with rapid rise time, the influence of the square voltage frequency on PD activity should be investigated (1) to suggest values for the repetitive square voltage frequency selection for the PDIV and lifetime tests, and (2) to increase the signal-to-noise ratio when extracting PD pulses from strong disturbances generated by the operating switch of impulse generators. Therefore, the main purpose of this paper was to investigate the effects of repetitive square voltage frequency on PD events. Insulation models of both Type I (low-voltage inverter-fed motor) and Type II (high-voltage inverter-fed motor) were used to obtain single-PD and multi-PD statistical features, respectively. Experimental results indicated that higher frequencies caused less PD events with lower PD magnitudes and shorter delay times in one square voltage cycle. This phenomenon was attributed to the different surface charge decay ratios and the initial electron emission probabilities resulting from different square voltage frequencies. Finally, a number of considerations for PD measurements on inverter-fed motors were provided to improve the sensitivity of the PD test system and to obtain high objective insulation lifetime test results, which are used to assess the insulation status of inverter-fed motors.

Partial Discharge Activity of Inter-turn Insulation under Different Parameters of Square Wave Voltage

Effect of Waveform Parameters of High Voltage Square-wave Pulse on Partial Discharge

Partial Discharge Characteristics of Interturn Insulation Used for Inverter-Fed Traction Motor under Bipolar Impulses

Effect of Repetitive Square Voltage Frequency on Partial Discharge Features

Comparison of Partial Discharge Characterizations under 60 Hz Sinusoidal Waveform and High-frequency PWM Waveform

Phase Distribution Characteristics of Partial Discharge under Square Pulse Voltage

Partial Discharge Characteristics of Inverter-fed Motor Insulation at Repetitive Square Wave Voltages

Partial Discharge Patterns of Oil-Paper Insulation under AC Voltage Superimposed Harmonics

Effects of Discharge Area and Surface Conductivity on Partial Discharge Behavior in Voids under Square Voltages

Partial Discharge Characteristics of Oil-Paper Insulation for On-Board Traction Transformers under Superposed Inter-Harmonic AC Voltages

Characteristics and Mechanism of Partial Discharge Behavior of Power Module Under Unipolar Square Voltage

Study of Partial Discharge Characteristics at Repetitive Square Voltages Based on UHF Method

Partial Discharge Investigation under Humidity Conditions Via Dissipation Factor and Insulation Capacitance Tip-Up Test

Partial Discharge Characteristics and Mechanism in Voids at Impulse Voltages

Review of Partial Discharge Activity Considering Very-Low Frequency and Damped Applied Voltage

Partial Discharge Behaviors Excited by High-Frequency Square Pulse Voltage in Cast Resin Insulation with Thermal-Induced Defect

Characterizations of Partial Discharge in Modern Power Electronics

Analysis of Aging Properties for Insulation Based on Statistical Parameters of Partial Discharge Under Pulse Voltage

Frequency-Induced Inflection Point Phenomenon and Formation Mechanism of Partial Discharge with Polyimide Films

Partial Discharge Development in Needle-Plane Configuration of Oil-Paper Insulation under AC Voltage

Evolution of Partial Discharge of Oil-Paper Insulation under Long-Term AC Voltage