Abstract:Atomic recoil events on free surfaces orthogonal to two different anti-phase boundaries (APBs) and two grain boundaries (GBs) in Ni3Al are simulated using molecular dynamics methods. The threshold energy for sputtering, E sp, and adatom creation, E ad, are determined as a function of recoil direction. The study is relevant to FEG STEM (a scanning transmission electron microscope fitted with a field emission gun) experiments on preferential Al sputtering and/or enhancement of the Ni–Al ratio near boundaries. Surfaces intersected by {110} and {111} APBs have minimum E sp of 6.5 eV for an Al atom on the Ni–Al mixed (M) surface, which is close to the value of 6.0 eV for a perfect M surface. High values of E sp of an Al atom generally occur at a large angle to the surface normal and depend strongly on the detailed atomic configuration of the surface. The mean E sp, averaged over all recoil directions, reveals that APBs have a small effect on the threshold sputtering. However, the results for E ad imply that an electron beam could create more Al adatoms on surfaces intersected by APBs than on those without. The equilibrium, minimum energy structures for a (001) surface intersected by either Σ5[001](210) or Σ25[001](340) symmetric tilt grain boundaries are computed. E sp for surface Al atoms near these GBs increases monotonically with increasing recoil angle to the surface normal, with a minimum value, which is only about 1 eV different from that obtained for a perfect surface. Temperature up to 300 K has no effect on this result. It is concluded that the experimental observations of preferential sputtering are due to effects beyond those for E sp studied here. Possible reasons for this are discussed.

Energy Distributions of Atoms Sputtered from Cu-Pt Alloy Measured by Nonresonant Multiphoton Ionization Sputtered Neutrals Mass Spectrometry

Measurements of angular distributions of sputtered material as a new tool for surface-segregation studies: Segregation in CuPt alloys

Sputtering of CuPt Alloy

Study of ion sputtering on AlxSn100-x alloy system

SPUTTERING RESEARCH OF Al-50wt％Sn ALLOY

DYNAMIC PROCESSES OF ALTERED LAYER FORMATION IN Cu-Pt ALLOYS UNDER ION BOMBARDMENT

Bombardment-induced Segregation of Cu in Pt-Cu Alloy Observed Using Different Energy Auger Line Combinations

Composition Profiles at Initial Stage of Altered Layer Formation on Cu-Pt Alloy Surfaces under Ar+ Ion Bombardment

Study of low energy sputtering of Pt(111) surface by molecular dynamics simulation

SPUTTERING RELATED PHENOMENA ON THE SURFACE OF Pb97.4Sn2.6 ALLOY

Electronic Structure of Nanoscale Cu/Pt Alloys: A Combined X-Ray Diffraction and X-Ray Absorption Investigations

Potential Sputtering by Highly Charged Ion Bombardment on Au Surface

The Relative Alloy Sensitivity Factor of the Pt-Cu System

Ion beam sputtering of silicon: Energy distributions of sputtered and scattered ions

Measurement of mass-angle and mass-total kinetic energy distributions from the fission of Pt compound nucleus

The Effect of Cooling on the Development of Composition Profiles in Cu–Pt Alloys under Ar+ Ion Bombardment

Sputtering Induced by Highly Charged 208pbq+ Bombardment on Al Surface

Point-Defect Properties of and Sputtering Events in the {001} Surfaces of Ni3al - I. Surface and Point-Defect Properties

Low-energy Sputtering Events at Free Surfaces Near Anti-Phase and Grain Boundaries in Ni3Al

Accurate argon cluster-ion sputter yields: Measured yields and effect of the sputter threshold in practical depth-profiling by x-ray photoelectron spectroscopy and secondary ion mass spectrometry

Single-electron-detachment cross sections of Fe− , Ru− , Ni− , Pd− , and Pt− in collisions with inert-gas atoms