Abstract:Aiming for the application of refrigerant two-phase cooling on battery thermal management, this study presented an experimental investigation on the flow boiling characteristics of R1233zd(E) in a parallel mini-channel heat sink, which consisted of 21 channels with the length of 140 mm and the cross section of 1.5 x 1.5 mm(2). Under the saturation pressure of 125 kPa, the boiling curve of R1233zd(E) and the heat transfer coefficient were analyzed under different heat fluxes (5-100 kW/m(2)), mass fluxes (150-600 kg/m(2) s) and inlet subcoolings (2.5-8 K). In addition, the flow pattern was captured using high-speed camera. The results showed that the onset of nucleate boiling was delayed with the increase of refrigerant mass flux and inlet subcooling, while the transition of heat transfer was verified by flow pattern visualization. The measured wall superheat was compared with present correlations, showing that the predicted value was always smaller than the experimental results. Flow boiling on local points showed that the nucleate boiling was triggered later at the channel located at the center axis of the heat sink, meanwhile the approach of critical heat flux was more obvious at channel outlet. Due to the graduate transition of flow boiling mechanism, refrigerant mass flux had limited influence on the local heat transfer coefficient when the heat flux was lower than 30 kW/m(2), while enhancement on heat transfer could be observed with larger mass flux when the heat flux exceeded 30 kW/m(2). The local experimental data of heat transfer coefficient were compared with 6 correlations from the literatures. It was found that the best prediction was presented by Liu and Winterton model with a MAE of 23.4%, while Kim and Mudawar model showed best agreement under different mass fluxes. A simple modification was conducted on Kim and Mudawar model, and the calibrated model presented a better prediction accuracy with the MAE of 17.6% and 83.2% of total data within the error of +/- 30%. (C) 2021 Elsevier Ltd. All rights reserved.

A new predictive tool for saturated critical heat flux in micro/mini-channels: Effect of the heated length-to-diameter ratio

An Analysis Of Saturated Critical Heat Flux In Micro/Mini-Channels

Saturated Flow Boiling Heat Transfer of R1233zd(E) in Parallel Mini-Channels: Experimental Study and Flow-Pattern-based Prediction

Experimental Investigation on Flow Boiling Instability of R1233zd(E) in a Parallel Mini-Channel Heat Sink for the Application of Battery Thermal Management

Simple Flow-Pattern Based Heat Transfer Correlations For Flow Boiling In Micro/Minichannels

Correlations for Saturated Critical Heat Flux in Microchannels

A General Criterion for Evaporative Heat Transfer in Micro/Mini-Channels

Predictive Modeling for Microchannel Flow Boiling Heat Transfer under the Dual Effect of Gravity and Surface Modification

Experimental investigation and a mechanical model of critical heat flux in a narrow rectangular channel

Numerical investigation of critical heat flux during subcooled flow boiling in a vertical rectangular Mini-channel

Experimental investigation on heat transfer of subcooled flow boiling of water in mini channels under high heat fluxes

Numerical Investigation of Flow Boiling Characteristics in Narrow Rectangular Channels Using Two-Fluid Eulerian Cfd Model Covering a Wide Range of Pressures

Data-Driven Dimensional Analysis of Critical Heat Flux in Subcooled Vertical Flow: A Two-Stage Machine Learning Approach

A New Correlation For Subcooled Flow Boiling Heat Transfer In A Vertical Narrow Microchannel

Local Heat Transfer of Saturated Flow Boiling in Vertical Narrow Microchannel

Numerical simulation of boiling behavior in vertical microchannels

A Critical Heat Flux Model for Saturated Flow Boiling on the Downward Curved Heated Surface

Evaporative annular flow in micro/minichannels: A simple heat transfer model

Local Heat Transfer in Subcooled Flow Boiling in a Vertical Mini-Gap Channel

THE EFFECT OF CHANNEL HEIGHT ON FLOW BOILING HEAT TRANSFER AND CHF IN FLAT MINICHANNELS WITH LOCAL HEATING

HEAT TRANSFER CHARACTERISTICS OF WATER FLOWING THROUGH MICROCHANNELS