Abstract:The electrical and optical properties of sol–gel derived aluminum-doped zinc oxide thin films containing 2 at.% Al were investigated considering the modifying effects of (1) increasing the sol H2O content and (2) a thermal treatment procedure with a high-temperature approach followed by an additional heat-treatment step under a reducing atmosphere. According to the results obtained via the TG-DTA analysis, FT-IR spectroscopy, X-ray diffraction technique, and four-point probe resistivity measurements, it is argued that in the modified sample, the sol hydrolysis, decomposition of the deposited gel, and crystallization of grains result in grains of larger crystallite size in the range of 20 to 30 nm and a stronger c-axis preferred orientation with slightly less microstrain. The obtained morphology and grain-boundary characteristics result in improved conductivity considering the resistivity value below 6 mΩ·cm. A detailed investigation of the samples’ optical properties, in terms of analyzing their absorption and dispersion behaviors through UV-Vis-NIR spectroscopy, support our reasoning for the increase of the mobility, and to a lesser extent the concentration of charge carriers, while causing only a slight degradation of optical transmittance down to nearly 80%. Hence, an enhanced performance as a transparent conducting film is claimed for the modified sample by comparing the figure-of-merit values.

Optimization of the Process for Preparing Al-doped ZnO Thin Films by Sol-Gel Method

Surface Topography and Optical Properties of Al-doped ZnO Thin Films by Sol-gel Process

Preparation and Characterization of Na-doped ZnO Thin Films by Sol–gel Method

Effect of heat treatment on microstructure and transparent conducting properties of sol-gel ZnO/Al thin films

Preparation and Characterization of Mg-doped ZnO Thin Films by Sol–gel Method

THERMAL DECOMPOSITION AND CRYSTALLIZATION PROCESS OF ZnO:Al THIN FILMS VIA SOL-GEL ROUTE

Microstructue and Optical Properties of Mg-doped ZnO Thin Films Prepared by Sol-gel Method

Enhanced photocatalytic activity of Mg 0.05 Zn 0.95 O thin films prepared by sol–gel method through a cycle

Surface Morphology and Optical Properties of Na-doped ZnO Thin Films

Microstructure and Electrical Properties of Al-doped ZnO Thin Films

Sol-Gel Preparation of Ag/ZnO Films and Their Electrical and Optical Properties

Study on Microstructure and Electrical Properties of ZnO:Al Thin Films Prepared by Sol-gel Method

Enhanced Sol–Gel Route to Obtain a Highly Transparent and Conductive Aluminum-Doped Zinc Oxide Thin Film

Preparation and optical characteristics of ZnO films by chelating sol-gel method

(0 0 2)-Oriented Growth and Morphologies of ZnO Thin Films Prepared by Sol-Gel Method

Growth Of The Sol-Gel Based Zno:Al Thin Films With High Doping Concentration

Effect of Al-doping on Crystallinity and Microstructure of ZnO:Al Thin Films

Preparation of Aluminum Doped Zinc Oxide Films with Low Resistivity and Outstanding Transparency by a Sol–gel Method for Potential Applications in Perovskite Solar Cell

Optical and structural properties of Al-doped ZnO thin films by sol gel process

Preparation of Al-doped Zinc Oxide (ZAO) Thin Film by Sol-Gel Process and Its Near-Infrared Reflective Properties

Investigation into Texture, Preferential Orientation, and Optical Properties of Zinc Oxide Nanopolycrystalline Thin Films Deposited by the Sol–Gel Technique on Different Substrates