Abstract:Characteristics of single-phase convective heat transfer in a rectangular channel are reported for heated and non-heated conditions. Results indicated that the friction factors were basically the same in the laminar region. However, in the transition and quasi-turbulent region, the heated friction factor was slightly lower than the non-heated values, and the value of non-uniform heating was slightly higher than that of uniform heating. The transition started critical Reynolds number increased from 2700 without heating to about 3000 with heating only due to the viscosity decreased with increasing temperatures. Due to the transition started and ended Reynolds number increased simultaneously under heating, the width of flow transition was almost the same as that without heating. The transverse power distribution influenced the average Nusselt number of the channel, although measured differences were small for uniform and non-uniform heating conditions. For the heat transfer data under uniform heating conditions obtained in this study, 15 correlations were evaluated. It is found that the existing correlations underestimated the experimental data for Re < 3000 and overestimated the data for 3000 < Re < 6000. A large database of heat transfer in rectangular channels including the experimental data obtained from this study and other researchers' work was established, and new heat transfer correlations for laminar (Re < 3000) and transition (3000 < Re < 10000) flows were developed. The Dittus-Boelter correlation was confirmed to provide a good prediction for the heat transfer for Re > 10000, with almost all data being within 20% errors.

Numerical Calculation of Fluid Flow and Heat Transfer in Asymmetrical Wavy Channels

Detailed Heat Transfer Measurements of Curved Fin Channels

Numerical investigation of heat transfer and fluid flow characteristics inside a wavy channel

Effects Of Corrugation Angle On Flow And Heat Transfer In Cross Corrugation Channels With Sinusoidal Waves

Numerical Analysis of Mixed Convective Heat Transfer In a Square Channel with Uniform Wall Temperature.

Numerical Prediction of Laminar Flow and Heat Transfer in Wavy Channels of Uniform Cross-Sectional Area

Effects of Intersection Angles on Flow and Heat Transfer in Corrugated-Undulated Channels With Sinusoidal Waves

A numerical analysis of fluid flow and heat transfer in wavy and curved wavy channels

Analysis of Fully-Developed Laminar-Flow and Heat-Transfer in Asymmetric Wavy Channels

Forced Heat Convection of Wavy Fin Channel

Numerical Study on the Characteristics of Flow and Heat Transferin Wavy Channels with Different Phase Shifts

Numerical investigation on slip-flow and heat transfer characteristics in the entrance region of elliptical microchannels

Numerical Study of Periodically Fully Developed Flow and Heat Transfer in Cross-Corrugated Triangular Channels in Transitional Flow Regime

Investigation of Turbulent Flow and Heat Transfer in Periodic Wavy Channel of Internally Finned Tube with Blocked Core Tube

Experimental Study of Single-Phase Flow and Heat Transfer in Rectangular Channels under Uniform and Non-Uniform Heating

COMPARISON STUDY OF FLOW AND HEAT TRANSFER CHARACTERISTICS IN TWO KINDS OF WAVY CHANNELS

Investigation Of Flow And Heat Transfer Characteristics In Rectangular Small/Microchannels

Numerical Study Of Laminar Flow And Heat Transfer Characteristic In Wave Tubes Based On Sine Curve

NUMERICAL STUDY OF CONVECTIVE HEAT AND MASS TRANSFER IN WAVY CHANNEL UNDER DEHUMIDIFYING CONDITIONS

A numerical study of laminar convective heat transfer in microchannel with non-circular cross-section☆

Numerical Simulation of Laminar Flow and Heat Transfer Characteristics in Elliptical Tubes