Abstract:In situ nanostructuring in bulk thermoelectric materials through thermo-dynamic phase segregation has established itself as an effective paradigm for optimizing the performance of thermoelectric materials. In bulk PbTe small compositional variations create coherent and semicoherent nanometer sized precipitates embedded in a PbTe matrix, where they can impede phonon propagation at little or no expense to the electronic properties. In this paper the nanostructuring paradigm is for the first time extended to a bulk PbS based system, which despite obvious advantages of price and abundancy, so far has been largely disregarded in thermoelectric research due to inferior room temperature thermoelectric properties relative to the pristine fellow chalcogenides, PbSe and PbTe. Herein we report on the synthesis, microstructural morphology and thermoelectric properties of two phase (PbS)(1-x)(PbTe)(x)x = 0-0.16 samples. We have found that the addition of only a few percent PbTe to PbS results in a highly nanostructured material, where PbTe precipitates are coherently and semicoherently embedded in a PbS matrix. The present (PbS)(1-x)(PbTe)(x) nanostructured samples show substantial decreases in lattice thermal conductivity relative to pristine PbS, while the electronic properties are left largely unaltered. This in turn leads to a marked increase in the thermoelectric figure of merit. This study underlines the efficiency of the nanostructuring approach and strongly supports its generality and applicability to other material systems. We demonstrate that these PbS-based materials, which are made primarily from abundant Pb and S, outperform optimally n-type doped pristine PbTe above 770 K.

Nanocrystals of the Quaternary Thermoelectric Materials: AgPbmSbTem+2 (m = 1–18): Phase‐Segregated or Solid Solutions?

Nanoscale Stabilization of New Phases in the PbTe-Sb2Te3 System: Pb(m)Sb(2n)Te(m+3n) Nanocrystals.

Solid-solutioned homojunction nanoplates with disordered lattice: a promising approach toward "phonon glass electron crystal" thermoelectric materials.

Size As a Parameter to Stabilize New Phases: Rock Salt Phases of PbmSb2nSem+3n

Elemental distributions within multiphase quaternary Pb chalcogenide thermoelectric materials determined through three-dimensional atom probe tomography

[O47] Phase equilibria of thermoelectric materials: Ag-Sb-Te and AgSbTe2-AgSbSe2

Mid-temperature Thermoelectric Performance of Zone-Melted Sb2(Te,Se)3 Alloys Near Phase Transition Boundary

Solution-Grown Ternary Semiconductors: Nanostructuring and Stereoelectronic Lone Pair Distortions in I–V–VI 2 Materials

Phase equilibria of Ag–Sb–Te thermoelectric materials

ChemInform Abstract: Composition Optimization of P‐Type AgSnmSbTem+2 Thermoelectric Materials Synthesized by Mechanical Alloying and Spark Plasma Sintering.

Ternary Eutectic Growth of Nanostructured Thermoelectric Ag-Pb-Te Materials

Controllable Synthesis and Thermoelectric Transport Properties of Binary-Phased Pbte/Pbse Nanocrystals

Nanostructures Boost the Thermoelectric Performance of PbS

Nanostructured AgPb18SbS20 compound synthesized by hydrothermal method

Colloidal Ag2SbBiSe4 nanocrystals as n‑type thermoelectric materials

Low-Temperature, Solution-Based, Scalable Synthesis of Sb2Te3 Nanoparticles with an Enhanced Power Factor

Solid‐State Janus Nanoprecipitation Enables Amorphous‐Like Heat Conduction in Crystalline Mg3Sb2‐Based Thermoelectric Materials

Controlled growth of bismuth antimony telluride Bi x Sb 2−x Te 3 nanoplatelets and their bulk thermoelectric nanocomposites

Sonochemical Synthesis of Nanocrystalline Bi2Te3 Thermoelectric Compounds

Syntheses of a series of BaCu 2− x Ag x Se 2 ( x = 0 – 1.0) selenides and evaluation of their thermoelectric properties

High thermoelectric performance and low thermal conductivity in Cu2−yS1/3Se1/3Te1/3 liquid-like materials with nanoscale mosaic structures