Abstract:The Zhundong coalfield has attracted ever-increasing attention as a result of its super-large reserve of coal resources. However, the power plants encounter great challenges in the utilization of Zhundong coal as a result of its high-alkali feature, which deteriorates the phenomenon of ash deposition and slagging. Oxy-fuel combustion of Zhundong coal benefits the near-zero emission of pollutants in coal-fired power plants, while previous studies mainly focused on the behaviors of alkali and alkaline earth metals and ash deposition during air combustion. The present study focused on the characteristics of ash deposition during oxy-fuel combustion of high-alkali coal, especially the differences in morphologies and chemical compositions of ash deposits using a drop-tube furnace, with the ash deposition mechanisms being further elucidated. Experimental results showed that the contents of sulfur (S), chlorine (Cl), and calcium (Ca) in ash deposits from oxy-fuel combustion were lower at the identical O-2 content but the contents of aluminum (Al) and silicon (Si) were increased in comparison to air conditions. The average particle size of ash deposits under oxy-fuel conditions was smaller with less calcium sulfate and mullite than the case in air combustion of Zhundong coal. The adhesion phenomenon between ash particles was aggravated in the ash deposits of high-alkali coal, with the oxygen content elevated. The proportion and diameters of spherical particles declined with an increasing oxygen concentration in the ash deposits of Zhundong coal. The contents of iron (Fe) and calcium in ash deposits of high-alkali coal were closely bound with the decrease of the melting point of ash and the formation of spherical ash particles. The caking phenomenon became more serious as the flue gas temperature was increased in the ash deposits of Zhundong coal. The deposition propensity of Zhundong coal was inclined to the minimum when the probe surface temperature was 550 degrees C, while the deposition propensity of Lu'an coal was different possibly as a result of the differences in coal properties and ash compositions. During the combustion of high-alkali coals, some components deteriorated ash deposition, including the low-temperature eutectics formed by the reactions of Fe and Ca with Si-Al compounds and sulfates and chlorides of sodium or calcium. This paper is beneficial for the improved understanding of ash deposition during oxy-fuel combustion of high-alkali coal.

Probe into Reasons of Ash Deposition in Oil-fired Organic Heat Transfer Material Heaters of a Certain Zhejiang Pharmaceutical Factory

Ash Deposition Mechanism and Composition Distribution Characteristics in Oil-fired Boiler

Formation of Ash Deposit Within Residual Oil Burning Boilers

Experimental Investigation of Ash Deposits on Convection Heating Surfaces of a Circulating Fluidized Bed Municipal Solid Waste Incinerator

Mechanism Research on the Development of Ash Deposits on the Heating Surface of Biomass Furnaces

Investigation of Ash Deposition Characteristics in Full-Scale Circulating Fluidized Bed Boiler Burning Zhundong Coal

Compositional and structural study of ash deposits spatially distributed in superheaters of a large biomass-fired CFB boiler

Investigation into the Ash Deposits in a Coal-Fired Traveling Grate Boiler with Ammonia Present in the Flue Gas

Experimental Study on the Effects of Reheat Temperatures on the Ammonium Bisulfate and Ash Blend Deposition

In Situ Diagnostics on the Dynamic Processes of Ash Deposit Formation, Shedding, and Heat Transfer in a Self-Sustained Down-Fired Furnace

Simulation of ash depositing in heat transfer surface with heat flux probe

EXPERIMENTAL STUDY OF ASH DEPOSIT DURING CO-FIRING SAWDUST AND COAL

Investigation on ash fouling formation of induced fan blade and heat exchanger surface in a 1000MW coal-fired power plant

An Experimental Study on Ash Deposition Problem of Low-Low Temperature Flue Gas System

Corrosion and Viscous Ash Deposition of A Rotary Air Preheater in A Coal-Fired Power Plant

Field Study on the Corrosion and Ash Deposition of Low-Temperature Heating Surface in a Large-Scale Coal-Fired Power Plant

An experimental investigation into bed particle agglomeration and ash deposition during circulating fluidized bed gasification of Zhundong lignite

Dynamic behavior of biomass ash deposition in a 25 kW one-dimensional down-fired combustor

Investigation of Ash Deposition Dynamic Process in an Industrial Biomass CFB Boiler Burning High-Alkali and Low-Chlorine Fuel

Ash Aerosol Partitioning and Ash Deposition During the Combustion of Petroleum Coke/natural Gas Mixtures

Experimental Study on Morphology and Chemical Composition of Ash Deposition During Oxy-fuel Combustion of High-Alkali Coal