Abstract:Superheated droplets vaporized in a vacuum or vapor chamber was studied using smoothed particle hydrodynamics method.The two-phase fluids of vapor and liquid with a diffused interface were modeled by Navier-Stokes-Korteweg equations,with the van der Waals equation of state.The liquid-vapor separation was processed with different initial temperature and density.Simulation was firstly validated by the proper equilibrium states with analytical data from the binodal line of Maxwell construction,as well as the droplet surface tension compared with experimental and other groups'numerical data in a good agreement.Droplet morphology,density,temperature and entropy increment were then carefully examined during the dynamic process from evaporation to boiling.Four phase transitions patterns were concluded,namely from surface evaporation,internal bubble,fragment and explosion,to flash boiling with increasing equivalent superheat degree that is defined by the non-dimensional superheat temperature over surface tension.Results showed that droplet temperature and density decreased slightly at surface evaporation when equivalent superheat degree was lower than 1/3.Above this criterion,the internal bubble could be sustained.Growth of new liquid nucleates and connected secondary liquid ring were calculated by domain growth theory.We found that droplet continuous to expand at high superheat but withdrawn at equivalent superheat degree equal to or lower than 0.52.At equivalent superheat degree higher than 1,the growth and expansion of droplet resulted in liquid fragment and explosion to many small secondary droplets.Mean mass and diameter of these droplets were found to have power-law dependency on the expansion rate.Finally,fast flash boiling occurred at equivalent superheat degree higher than 3.The vapor pressure in the chamber showed a negative linear correlation between the overpressure and the atmospheric pressure.We also found out that comparing to increase the pressure value,dense gas had better efficiency on retarding the propagation of shock wave.

Two-dimensional numerical simulation of hydrodynamic behaviors of drop covered with vapor film

Numerical Simulation of Liquid Droplet Breakup in Supersonic Flows

Two-dimensional Simulation of Drop Deformation and Breakup at Around the Critical Weber Number

A consistent volume-of-fluid approach for direct numerical simulation of the aerodynamic breakup of a vaporizing drop

Simulation and modeling of the vaporization of a freely moving and deforming drop at low to moderate Weber numbers

Numerical Simulation of the Collision Behaviors of Binary Unequal-Sized Droplets at High Weber Number

Numerical Simulation for Combustion of Droplet with Volume of Fluid Formulation

Supercritical Vaporization of Two Droplets in Tandem in Convective Environments

Impact of vaporization on drop aerobreakup

Deformation Characteristics of Droplet Generated by Rayleigh Jet Breakup

Numerical Simulation of Liquid Droplet Coalescence and Breakup

Numerical simulation of the aerobreakup of a water droplet

A Comparative Study on the Breakup of Newtonian and Viscoelastic Liquid Films

Droplet Evaporation to Boiling in Van Der Waals Fluid

Three-Dimensional Simulation Of Effervescent Atomization Spray

Detailed numerical investigation of the drop aerobreakup in the bag breakup regime

Study on Instability Breakup of Fluid Droplet in Spray Process

Numerical Simulation of Drops Falling to and Splashing on Liquid Interfaces

Three-dimensional Numerical Simulation of Droplet Deposition

Numerical Simulation of Microscale Oblique Droplet Impact on Liquid Film

Numerical Simulations of Molten Breakup Behaviors of a de Laval-Type Nozzle, and the Effects of Atomization Parameters on Particle Size Distribution