Abstract:Bag breakup of drops has been a subject of interest for almost over a century. Several issues such as theoretical estimation of the regime boundary marking the onset of such breakup, bag growth rates, drop size distribution, and the effect of Weber number, $We$, and Ohnesorge number, $Oh$, on these quantities remains unaddressed. The current study aims to clarify aspects of the atomization process through experiments and theory. We examine bag breakup of a single drop of various inviscid and low viscosity fluids as it deforms in the presence of a continuous horizontal air jet. The We boundary at which bag breakup begins is theoretically determined and the expression obtained, $We = 12(1 + \frac{2}{3} Oh^2)$, is found to match well with existing experimental data. An exponential growth in the radial extent of the deformed drop and the streamline dimension of the bag is predicted by the theoretical model and confirmed by experimental findings. These quantities are observed to strongly depend on $We$. However, their dependence on $Oh$ is weak for the range of $Oh$ considered in this study. Subsequent to drop deformation, bag formation and expansion is the bursting process. This is marked by the disintegration of the bag owing to instability of the Rayleigh-Taylor type, followed by collapse of the liquid rim bounding this bag by Plateau-Rayleigh instability. The sizes of the drops thus produced are measured using Phase Doppler Anemometry (PDA) which is in contrast to shadowgraphs used in earlier studies. A discernible shift in the peak of the drop size distribution for viscous drops is seen which indicates a preponderance of drops of higher diameters vis-à-vis fragment size distribution for inviscid drops. Furthermore, an estimate of the Sauter mean diameter ($D_{32}$) is presented which is somewhat lower than earlier predictions.

Detailed numerical investigation of the drop aerobreakup in the bag breakup regime

Characterization of the Bag Breakup of Liquid Drop Using High-Speed Digital In-Line Holography

Bag breakup of low viscosity drops in the presence of a continuous air jet

Impact of vaporization on drop aerobreakup

An analytical and experimental study of secondary atomization for vibrational and bag breakup modes

Visualization Research of Droplet Deformation and Breakup in the Multimode Regime

Droplet Bag Formation in Turbulent Airflows

Bag Film Breakup of Droplets in Uniform Airflows

Two-dimensional Simulation of Drop Deformation and Breakup at Around the Critical Weber Number

A consistent volume-of-fluid approach for direct numerical simulation of the aerodynamic breakup of a vaporizing drop

Droplet Deformation and Breakup in a Continuous Gas Flow

Characterization of Drop Aerodynamic Fragmentation in the Bag and Sheet-Thinning Regimes by Crossed-Beam, Two-View, Digital In-Line Holography

A New Breakup Regime of Liquid Drops Identified in a Continuous and Uniform Air Jet Flow

Breakup Characteristics of Liquid Drops in Bag Regime by a Continuous and Uniform Air Jet Flow

Deformation Characteristics of Droplet Generated by Rayleigh Jet Breakup

Experimental Study of Drop Size Distribution in the Bag Breakup Regime

Simulation and modeling of the vaporization of a freely moving and deforming drop at low to moderate Weber numbers

Experimental Statistics of Micrometer-Sized Water Droplet Deformation and Breakup Behavior in Continuous Air Jet Flow

Experimental Study on Droplet Breakup in an Orifice Jet Mixer

Single and two-phase fluid droplet breakup in impulsively generated high-speed flow

Transitions of Deformation to Bag Breakup and Bag to Bag-Stamen Breakup for Droplets Subjected to a Continuous Gas Flow