Abstract:This study presents the development of an improved technique for viscosity measurements under high pressure. The apparatus is based on the principle of the falling ball viscometer, implemented in a high-pressure autoclave fitted with visualisation windows. The originality here is that the balls fall through a tube open at both ends with a diameter slightly greater than that of the balls, allowing a simplified modelling and numerical simulation. A numerical approach has been used for viscosity determination. Calculations have been made with COMSOL Multiphysics® with the laminar Navier–Stokes model for Newtonian mixtures. It includes the specific hydrodynamic effects without the need for a calibration fluid. However, validation experiments were carried out at atmospheric pressure with dimethylsulfoxide (DMSO) at 298, 308 and 318K and with cocoa butter at 313 and 353K, with values of viscosity in the range from 1.4 to 45.4mPas. Comparative measurements with literature data have been conducted with cocoa butter saturated with carbon dioxide at 313 and 353K and for pressures ranging from 0.1 to 25MPa. At 313K, viscosity varies from 45.4mPas to 3.1mPas while at 353K it varies from 12.4 to 1.9mPas. For both isotherms tested, within the range 0–15MPa, the higher the CO2 dissolution in the cocoa butter, the lower the viscosity. However, this decrease in viscosity is more pronounced at the lowest temperature. Above 15MPa the CO2 dissolution effect on viscosity becomes insignificant, i.e. within the experimental error, due to a counter effect linked with the high hydrostatic pressure. Furthermore, the limits of use of this method have been determined. This technique is revealed as reliable and can therefore be used with other binary systems.

A two-capillary viscometer for temperatures up to 473 K and pressures up to 100 MPa – operation and verification at low pressure

Two-capillary viscometer for temperatures and pressures relevant to CO 2 capture, transport, and storage – operation and improved analysis at high pressure

Development of an improved falling ball viscometer for high-pressure measurements with supercritical CO2

Apparatus to measure density and viscosity of high-pressure carbon dioxide–alcohol mixtures

Validation of an accurate vibrating-wire densimeter: Density and viscosity of liquids over wide ranges of temperature and pressure

Utilization of a High-Pressure Vibrating Tube Densimeter for Liquids at Temperatures Down to 100 K

A New Method for Liquid Viscosity Measurements: Inclined-Tube Viscometry

Development of a Viscosity Measuring Device for Low Boiling Point Refrigerant Mixtures

Viscosity Measurements of the H-2-CO2, H-2-CO2-CH4, and H-2-H2O Mixtures and the H-2-CO2-CH4-CO-H2O System at 280-924 K and 0.7-33.1 MPa with a Capillary Apparatus

Volumetric behaviour of (carbon dioxide + hydrocarbon) mixtures at high pressures

Measurements of the Viscosity of Hydrogen and a (Hydrogen + Methane) Mixture with a Two-Capillary Viscometer

Viscosity Measurements of the H2–CO2, H2–CO2–CH4, and H2–H2O Mixtures and the H2–CO2–CH4–CO–H2O System at 280–924 K and 0.7–33.1 …

Design of a Capillary Viscometer System for the Determination of Polymer Solution Viscosity

High-Pressure Measurements of Temperature and CO2 Concentration Using Tunable Diode Lasers at 2 μm

Simultaneous measurement of the density and viscosity for n-Decane + CO2 binary mixtures at temperature between (303.15 to 373.15) K and pressures up to 80 MPa

Simultaneous measurement of density and viscosity of n-pentane from 298 to 383 K and up to 100 MPa using a vibrating-wire instrument

Liquid Density Measurement in High-Pressure Region Using Quartz Crystal Resonators

Development and Metrological Characterization of a Tunable Diode Laser Absorption Spectroscopy (TDLAS) Spectrometer for Simultaneous Absolute Measurement of Carbon Dioxide and Water Vapor

Density Measurements on Binary Mixtures (nitrogen + Carbon Dioxide and Argon + Carbon Dioxide) at Temperatures from (298.15 to 423.15) K with Pressures from (11 to 31) MPa Using a Single-Sinker Densimeter

Viscosity Measurements of Nitrogen and Argon at Temperatures from 90 K to 200 K and Pressures Up To 5 MPa

A constant pressure flowmeter for extreme-high vacuum