Abstract:High-value comprehensive utilization of coal gangue solid waste, reducing synthesis cost and environmental hazards has become an important research direction for green development. In this study, acid–alkali treated coal gangue was used as the silica source, and abundant cotton short staple in Xinjiang was used as the raw material of aerogel. Cellulose/SiO 2 composite aerogels were prepared by sol–gel method using N–N methylenebisacrylamide (MBA) as cross-linking agent and hydrochloric acid (HCl) as catalyst. The samples were characterized and analyzed by XRD, SEM, FT-IR, XPS, EDS, BET, and mechanical property tests. The results show that the composites exhibit low density and high porosity. The density ranges from 0.118–0.290 g/cm −3 with a high porosity of 92.5%. SEM and BET results showed that the composites showed a three-dimensional mesh structure, and the specific surface area was as high as 325.742 m 2 /g, with a pore size of 21.997 nm, which is a mesoporous material. The adsorption performance of the composite aerogel was tested by simulating wastewater with the dye methylene blue (MB), which showed that the adsorption amount of MB was 82.3 mg/g, and the adsorption amount showed a tendency of increasing and then decreasing with the increase of SiO 2 , and adsorption kinetics, adsorption isotherm and adsorption thermodynamic models were established to investigate the adsorption mechanism. The results showed that the adsorption process was more in line with the proposed secondary kinetics and Langmuir isothermal adsorption, which indicated that the adsorption process was a synergistic action of chemical adsorption and physical adsorption, and it was a monomolecular layer adsorption; thermodynamically, the adsorption process belonged to the spontaneous exothermic reaction. In addition, we explored the cyclic regeneration performance of the material, and after 5 cycles of adsorption experiments, the decrease rate was 3.9%, presenting good cyclic regeneration. Therefore, the results of this study provide new ideas and methods in solving the problem of environmental pollution caused by excessive accumulation of coal gangue, as well as providing a good new application prospect for composite aerogel and a theoretical basis for the development of low-cost new advanced materials.

Ambient-Dried Silica Aerogel Powders Derived from Coal Gangue by Using One-Pot Method

Robust SiO2–Al2O3/Agarose Composite Aerogel Beads with Outstanding Thermal Insulation Based on Coal Gangue

Fiber-Reinforced Coal Gangue-Based Alumina Aerogel Composites with Highly Thermal Stability by Ambient Pressure Drying

Synthesis and Characterization of Silica Aerogel and Its Composite Materials

Recycling Coal Fly Ash for Super-Thermal-Insulating Aerogel Fiber Preparation with Simultaneous Al2O3 Extraction

A novel low-cost method of silica aerogel fabrication using fly ash and trona ore with ambient pressure drying technique

Synthesis and Surface Strengthening Modification of Silica Aerogel from Fly Ash

Recycling Coal Fly Ash for Super-Thermal-Insulating Aerogel Fiber Preparation with Simultaneous Al 2 O 3 Extraction.

Recycling Coal Fly Ash for Super-Thermal-Insulating Aerogel Fiber Preparation with Simultaneous Al<sub>2</sub>O<sub>3</sub> Extraction

Synthesis of high specific surface area silica aerogel from rice husk ash via ambient pressure drying

A Facile Strategy for Freeze-Drying Preparation of Silica Aerogel from Sodium Silicate

Preparation and adsorption properties of cotton linters and coal-gangue-based cellulose/SiO2 composite aerogels

Enhancing Mesopore Volume and Thermal Insulation of Silica Aerogel via Ambient Pressure Drying-Assisted Foaming Method

Novel atmospheric pressure drying method for silica-based aerogel insulation: Inspired with the adult process of damselflies

Preparation of Silica Aerogels Via Ambient Pressure Drying

Silica aerogels formed from soluble silicates and methyl trimethoxysilane (MTMS) using CO2 gas as a gelation agent

Fumed Silica-Derived, Ambient Dried, and Low-Cost Nanoporous Aerogel-like Monoliths for Thermal Insulation

Facile Synthesis of Flexible and Hydrophobic Polymethylsilsesquioxane Based Silica Aerogel Via the Co-Precursor Method and Ambient Pressure Drying Technique

Preparation of Precipitated Nano-silica from Acid Leaching Residue of Coal Ash by Carbonation Method

A Fast Synthesis of Silica Aerogel Powders-Based on Water Glass Via Ambient Drying

Rapid and inexpensive synthesis of liter-scale SiC aerogels