Abstract:The effect of fortifying reconstituted skim milk with increasing levels of the beta-lactoglobulin (beta-LG) genetic variants A, B, and an A-B mixture on rennet-induced gelation was studied by small deformation-sensitive rheology. Free-zone capillary electrophoresis and high-sensitivity oscillatory rheology were used to elucidate the role of potential heterotypic associative interactions between whey proteins and casein in a mixed colloidal system, subjected to moderate heating (65 degrees C for 30 min) prior to renneting, on the gelling properties of the system. Increasing levels of added whey protein, in the concentration range of 0.225 to 1.35% of added protein, led to a concomitant progressive increase in the equilibrium shear storage modulus, G' (recorded after approximately 10,800 s), in the order beta-LG B > beta-LG A and beta-LG A-B, as the general expected consequence of the setup of denser casein gel networks. The preferential effect of beta-LG B over beta-LG A on the mechanical strength of the gels may be due to the formation of cross-links and aggregates involving whey proteins and rennet hydrolysis products or an increase in the size of the casein micelle caused by the grafting of beta-LG B to its surface, or both. The results of free-zone capillary electrophoresis were consistent with the notion that beta-LG B (and not beta-LG A) binds to the casein micelle under an optimal stoichiometry of 1:0.045 (mg/mg), even in the absence of heat treatment. The liquid-like character of the gel networks formed, tan delta, was a parameter sensitive to the level of addition of beta-LG A in particular. At low concentrations (up to 0.45%) of beta-LG A, tan delta increased by almost twice as much, which was interpreted as a result of the increase in the loss modulus, G'', of the sol fraction because of the presence of unbound beta-LG A. At greater incremental concentrations of beta-LG (>0.45%), the formation of smaller whey protein aggregates confined to the sol fraction may have led to a progressive decrease in tan delta. The critical gel time, t(gel), was also affected by the concentration of added whey protein and described 3 zones of behavior, irrespective of the type of whey protein variant. The critical gel time was slightly shorter for beta-LG B than for beta-LG A at 0.45% of added whey protein, but this difference became larger at 0.67%. Even when only beta-LG B was found to associate with casein prior to renneting, both beta-LG A and beta-LG B, either alone or mixed, had a profound influence on the mechanical strength and coagulation kinetics of the rennet-induced casein gels. This knowledge is expected to be useful to exert better control and optimize processing conditions during the manufacturing of cheese and cheese analogs.

Enzyme-induced gelation of extensively hydrolyzed whey proteins by alcalase: comparison with the plastein reaction and characterization of interactions

Fabrication and characterisation of whey–pea protein‐based emulsion gels induced by transglutaminase cross‐linking

Multi-dimensional analysis of heat-induced soybean protein hydrolysate gels subjected to ultrasound-assisted pH pretreatment

Aggregation of Whey Protein Hydrolysate Using Alcalase 2.4 L

Hydrolysis by Indigenous Plasmin: Consequences for Enzymatic Cross-Linking and Acid-Induced Gel Formation of Non-Micellar Casein

Formation of thermal-induced microgels from soy protein hydrolysates: Effects of selective proteolysis on glycinin/β-conglycinin

Effect of enzymatic hydrolysis on the formation and structural properties of peanut protein gels

Power Law Behavior of Structural Properties of Protein Gels

Digestion of milk protein gels in simulated gastric environment: exploration of the disintegration process and diffusion behavior of pepsin

Effect of β-Lactoglobulin A and B Whey Protein Variants on the Rennet-Induced Gelation of Skim Milk Gels in a Model Reconstituted Skim Milk System

Study on the rheological properties of heat-induced whey protein isolate-dextran conjugate gel

Acid-Induced Gelation of Enzymatically and Nonenzymatically Cross-Linked Caseins-Texture Properties, and Microstructural Insights

Batch versus microfluidic emulsification processes to produce whey protein microgel beads from thermal or acidic gelation

Effect of Ethanol on the Textural Properties of Whey Protein and Egg White Protein Hydrogels during Water-Ethanol Solvent Exchange

Enzymatic Sol-Gel Transition in Milk

Enzymatic-induced Gelation Properties of Protein Isolates from Phaseolus

Cold-Set Globular Protein Gels: Interactions, Structure and Rheology as a Function of Protein Concentration

The role of amyloid fibrils in the modification of whey protein isolate gels with the form of stranded and particulate microstructures

Further Stabilization of Alcalase Immobilized on Glyoxyl Supports: Amination Plus Modification with Glutaraldehyde

Preparation of ingredients containing an ACE-inhibitory peptide by tryptic hydrolysis of whey protein concentrates

Pea and soy protein isolate fractal gels: The role of protein composition, structure and solubility on their gelation behaviour