Abstract:The effect of fortifying reconstituted skim milk with increasing levels of the beta-lactoglobulin (beta-LG) genetic variants A, B, and an A-B mixture on rennet-induced gelation was studied by small deformation-sensitive rheology. Free-zone capillary electrophoresis and high-sensitivity oscillatory rheology were used to elucidate the role of potential heterotypic associative interactions between whey proteins and casein in a mixed colloidal system, subjected to moderate heating (65 degrees C for 30 min) prior to renneting, on the gelling properties of the system. Increasing levels of added whey protein, in the concentration range of 0.225 to 1.35% of added protein, led to a concomitant progressive increase in the equilibrium shear storage modulus, G' (recorded after approximately 10,800 s), in the order beta-LG B > beta-LG A and beta-LG A-B, as the general expected consequence of the setup of denser casein gel networks. The preferential effect of beta-LG B over beta-LG A on the mechanical strength of the gels may be due to the formation of cross-links and aggregates involving whey proteins and rennet hydrolysis products or an increase in the size of the casein micelle caused by the grafting of beta-LG B to its surface, or both. The results of free-zone capillary electrophoresis were consistent with the notion that beta-LG B (and not beta-LG A) binds to the casein micelle under an optimal stoichiometry of 1:0.045 (mg/mg), even in the absence of heat treatment. The liquid-like character of the gel networks formed, tan delta, was a parameter sensitive to the level of addition of beta-LG A in particular. At low concentrations (up to 0.45%) of beta-LG A, tan delta increased by almost twice as much, which was interpreted as a result of the increase in the loss modulus, G'', of the sol fraction because of the presence of unbound beta-LG A. At greater incremental concentrations of beta-LG (>0.45%), the formation of smaller whey protein aggregates confined to the sol fraction may have led to a progressive decrease in tan delta. The critical gel time, t(gel), was also affected by the concentration of added whey protein and described 3 zones of behavior, irrespective of the type of whey protein variant. The critical gel time was slightly shorter for beta-LG B than for beta-LG A at 0.45% of added whey protein, but this difference became larger at 0.67%. Even when only beta-LG B was found to associate with casein prior to renneting, both beta-LG A and beta-LG B, either alone or mixed, had a profound influence on the mechanical strength and coagulation kinetics of the rennet-induced casein gels. This knowledge is expected to be useful to exert better control and optimize processing conditions during the manufacturing of cheese and cheese analogs.

Enzymatic Sol-Gel Transition in Milk

Gelation of recombined soymilk and cow's milk gels: Effect of homogenization order and mode of gelation on microstructure and texture of the final matrix

Formation and Physical Properties of Milk Protein Gels

Two-step aging dynamics in enzymatic milk gels

Rheological and structural properties of acid-induced milk gels as a function of β-casein phenotype

Effect of Enzyme Modified Soymilk on Rennet Induced Gelation of Skim Milk

Intragastric restructuring dictates the digestive kinetics of heat-set milk protein gels of contrasting textures

GELATION OF MIXTURES OF SOYMILK AND RECONSTITUTED SKIM MILK SUBJECTED TO COMBINED ACID AND RENNET

Digestion of milk protein gels in simulated gastric environment: exploration of the disintegration process and diffusion behavior of pepsin

Acid-Induced Gelation of Enzymatically and Nonenzymatically Cross-Linked Caseins-Texture Properties, and Microstructural Insights

Effects of endogenous small molecular compounds on the rheological properties, texture and microstructure of soymilk coagulum: Removal of phytate using ultrafiltration

Effect of β-Lactoglobulin A and B Whey Protein Variants on the Rennet-Induced Gelation of Skim Milk Gels in a Model Reconstituted Skim Milk System

Dextran modulates physical properties of rennet‐induced milk gels

Evaluation of the yield, molar mass of exopolysaccharides, and rheological properties of gels formed during fermentation of milk by Streptococcus thermophilus strains St-143 and ST-10255y

Tribo-rheology and kinetics of soymilk gelation with different types of milk proteins

Rheology of protein-stabilised emulsion gels envisioned as composite networks. 1 -- Comparison of pure droplet gels and protein gels

Microstructural and textural properties of rennet-induced milk protein gel: Effect of guar gum

Formation of thermal-induced microgels from soy protein hydrolysates: Effects of selective proteolysis on glycinin/β-conglycinin

Rheological and structural properties of differently acidified and renneted milk gels