Abstract:The effect of fortifying reconstituted skim milk with increasing levels of the beta-lactoglobulin (beta-LG) genetic variants A, B, and an A-B mixture on rennet-induced gelation was studied by small deformation-sensitive rheology. Free-zone capillary electrophoresis and high-sensitivity oscillatory rheology were used to elucidate the role of potential heterotypic associative interactions between whey proteins and casein in a mixed colloidal system, subjected to moderate heating (65 degrees C for 30 min) prior to renneting, on the gelling properties of the system. Increasing levels of added whey protein, in the concentration range of 0.225 to 1.35% of added protein, led to a concomitant progressive increase in the equilibrium shear storage modulus, G' (recorded after approximately 10,800 s), in the order beta-LG B > beta-LG A and beta-LG A-B, as the general expected consequence of the setup of denser casein gel networks. The preferential effect of beta-LG B over beta-LG A on the mechanical strength of the gels may be due to the formation of cross-links and aggregates involving whey proteins and rennet hydrolysis products or an increase in the size of the casein micelle caused by the grafting of beta-LG B to its surface, or both. The results of free-zone capillary electrophoresis were consistent with the notion that beta-LG B (and not beta-LG A) binds to the casein micelle under an optimal stoichiometry of 1:0.045 (mg/mg), even in the absence of heat treatment. The liquid-like character of the gel networks formed, tan delta, was a parameter sensitive to the level of addition of beta-LG A in particular. At low concentrations (up to 0.45%) of beta-LG A, tan delta increased by almost twice as much, which was interpreted as a result of the increase in the loss modulus, G'', of the sol fraction because of the presence of unbound beta-LG A. At greater incremental concentrations of beta-LG (>0.45%), the formation of smaller whey protein aggregates confined to the sol fraction may have led to a progressive decrease in tan delta. The critical gel time, t(gel), was also affected by the concentration of added whey protein and described 3 zones of behavior, irrespective of the type of whey protein variant. The critical gel time was slightly shorter for beta-LG B than for beta-LG A at 0.45% of added whey protein, but this difference became larger at 0.67%. Even when only beta-LG B was found to associate with casein prior to renneting, both beta-LG A and beta-LG B, either alone or mixed, had a profound influence on the mechanical strength and coagulation kinetics of the rennet-induced casein gels. This knowledge is expected to be useful to exert better control and optimize processing conditions during the manufacturing of cheese and cheese analogs.

Effects of Ph and Ionic Strength on the Rheology and Microstructure of A Pressure-Induced Whey Protein Gel

Study on potential antigenicity and functional properties of whey protein treated by high hydrostatic pressure based on structural analysis

Kinetics of Microstructure Formation of High-Pressure Induced Gel from a Whey Protein Isolate

Power Law Behavior of Structural Properties of Protein Gels

Relations between rheological properties and network structure of soy protein gels

Effects of Ionic Strength on Chemical Forces and Functional Properties of Heat-induced Myofibrillar Protein Gel

Influence of partially demineralized milk proteins on rheological properties and microstructure of acid gels

Effect of the gelling mechanism on the physical properties of bigels based on whey protein isolate

Modulation of acid-induced pea protein gels by gellan gum and glucono-δ-lactone: Rheological and microstructural insights

Relation between gel stiffness and water holding for coarse and fine-stranded protein gels

Polyanion/gelatin complexes as pH-sensitive gels for controlled protein release

Structure Optimization and Mechanical Model for Microgel-Reinforced Hydrogels with High Strength and Toughness

Comparative Study of Heat- and Enzyme-Induced Emulsion Gels Formed by Gelatin and Whey Protein Isolate: Physical Properties and Formation Mechanism

Rheological, structural, and water-immobilizing properties of mung bean protein-based fermentation-induced gels: Effect of pH-shifting and oil imbedment

Influence of amyloid fibril length and ionic strength on WPI-based fiber-hydrogel composites: Microstructural, rheological and water holding properties

Binary Pea Protein–Psyllium Hydrogel: Insights into the Influence of pH and Ionic Strength on the Physical Stability and Mechanical Characteristics

Rheological Study on the Fractal Nature of the Protein Gel Structure

Effect of protein aggregation on rheological properties of pea protein gels

Factors that determine the fracture properties and microstructure of globular protein gels

Effect of β-Lactoglobulin A and B Whey Protein Variants on the Rennet-Induced Gelation of Skim Milk Gels in a Model Reconstituted Skim Milk System

The effect of agar on rheological properties and thermal stability of rennet-induced casein micelle gel