Abstract:Gas explosion in connected vessels usually leads to high pressure and high rate of pressure increase which the vessels and pipes can not tolerate. Severe human casualties and property losses may occur due to the variation characteristics of gas explosion pressure in connected vessels. To determine gas explosion strength, an experimental testing system for methane and air mixture explosion in a single vessel, in a single vessel connected a pipe and in connected vessels has been set up. The experiment apparatus consisted of two spherical vessels of 350 mm and 600 mm in diameter, three connecting pipes of 89 mm in diameter and 6 m in length. First, the results of gas explosion pressure in a single vessel and connected vessels were compared and analyzed. And then the development of gas explosion, its changing characteristics and relevant influencing factors were analyzed. When gas explosion occurs in a single vessel, the maximum explosion pressure and pressure growth rate with ignition at the center of a spherical vessel are higher than those with ignition on the inner-wall of the vessel. In conclusion, besides ignition source on the inner wall, the ignition source at the center of the vessels must be avoided to reduce the damage level. When the gas mixture is ignited in the large vessel, the maximum explosion pressure and explosion pressure rising rate in the small vessel raise. And the maximum explosion pressure and pressure rising rate in connected vessels are higher than those in the single containment vessel. So whenever possible, some isolation techniques, such as fast-acting valves, rotary valves, etc., might be applied to reduce explosion strength in the integrated system. However, when the gas mixture is ignited in the small vessel, the maximum explosion pressures in the large vessel and in the small vessel both decrease. Moreover, the explosion pressure is lower than that in the single vessel. When gas explosion happens in a single vessel connected to a pipe, the maximum explosion pressure occurs at the end of the pipe if the gas mixture is ignited in the spherical vessel. Therefore, installing a pipe into the system can reduce the maximum explosion pressure, but it also causes the explosion pressure growth rate to increase. (C) 2013 Elsevier Ltd. All rights reserved.

Large-scale experimental and simulation study on gas explosion venting load characteristics of urban shallow buried pipe trenches

Experimental and Numerical Evaluations on Characteristics of Vented Methane Explosion

Experimental study on vented explosion overpressure of methane/air mixtures in manhole

Explosion and vented explosion behaviors of low-concentration gas in large-scale pipes

Study on Gas Explosion Characteristics in Urban Utility Tunnels

A study of pressure characteristics of methane explosion in a 20 m buried tunnel and influence on structural behaviour of concrete elements

Experimental research on the venting characteristics of methane and coal dust two-phase system mixture explosions

Study on Explosion Venting Characteristics of L-Type Venting Duct

Experimental study on gas explosion and venting process in interconnected vessels

Experimental study on characteristics of flame propagation and pressure development evolution during methane-air explosion in different pipeline structures

A numerical study of gas explosion with progressive venting in a utility tunnel

Study of Multisource Leakage Diffusion and Explosion Risk of Underground Natural Gas Pipelines

Study on Gas Explosion Propagation Law and Explosion Venting in an Excavation Roadway

An overpressure-time history model of methane-air explosion in tunnel-shape space

Effect Analysis of the Venting Direction on Explosion Pressure in LPG Pipelines

Numerical study on over‐pressure performance of premixed explosion in utility tunnel

Effect of low gas concentration in underground return tunnels on characteristics of gas explosions

Experimental Study on Premixed Flammable Gas Explosion Venting in Linked Vessels under the Same Effictive Vent Area

Study on gas explosion propagation law in excavation roadway with TBM

Experimental Investigation of Gas Explosion in Single Vessel and Connected Vessels

Experimental Research On Gas Explosion Venting Of Premixed Gases In Linked Vessels