Abstract:Vented methane deflagrations in a 1 m3 vessel were investigated.Double flame acceleration phenomena were observed.CFD software FLACS was validated against experimental data.The mechanisms of the external overpressure peaks were revealed.The location of the external explosion was determined.This paper experimentally investigated the effect of low vent burst pressure on the overpressure buildup and flame evolution during the vented methane-air deflagrations in a 1 m3 rectangular vessel. CFD software FLACS was assessed in simulation of vented methane-air explosions against the experiment. Experimental results demonstrate that four overpressure peaks of Popen, Pout, Pext and Pacc from the vent failure, flame venting, external explosion and acoustically enhanced combustion, respectively, were observed except for the free venting case, in which only two overpressure peaks of Pout and Pext were monitored. The flame behaviors corresponding to different overpressure peaks were monitored especially at Pacc, where an abrupt increase in flame luminosity was observed on the bottom of the vessel due to the combustion of pockets of flammable mixture. Popen and Pacc increase with the vent burst pressure while Pout and Pext are nearly independent of the vent burst pressure. Double flame accelerations were observed owing to the vent rupture and flame venting. The phenomena of Helmholtz oscillation and the bulk motion of flame bubble always appeared after the vent rupture. The predicted overpressure agrees reasonably well with the experimental data. The discrepancy of the predicted and measured maximum peak overpressures reduces with increasing vent burst pressure. The predicted maximum peak overpressure and external flame length are slightly larger than those in experiment, which would facilitate the safe design in explosion venting and offer a better guidance in risk assessment. The simulation results also show that two overpressure peaks were recorded resulting from the pressure wave propagating above the vessel and the external explosion, respectively.

Experimental study on vented explosion overpressure of methane/air mixtures in manhole

An overpressure-time history model of methane-air explosion in tunnel-shape space

Large-scale experimental and simulation study on gas explosion venting load characteristics of urban shallow buried pipe trenches

A study of pressure characteristics of methane explosion in a 20 m buried tunnel and influence on structural behaviour of concrete elements

Study on Gas Explosion Characteristics in Urban Utility Tunnels

Experimental Study on the Venting Process of Methane-air Mixture Explosion

Experimental and Numerical Evaluations on Characteristics of Vented Methane Explosion

Experimental study on unconfined methane explosion: Explosion characteristics and overpressure prediction method

Numerical study on over‐pressure performance of premixed explosion in utility tunnel

Experimental research on the venting characteristics of methane and coal dust two-phase system mixture explosions

Experimental Research On Gas Explosion Venting Of Premixed Gases In Linked Vessels

Experimental and Numerical Study of Natural Gas Leakage and Explosion Characteristics.

Investigation on the characteristics of vented stoichiometric methane-air explosion: Effect of ignition positions and obstacles

Effects of methane volume fractions and vent areas on dynamic characteristics of vented methane-air explosion in a half-open duct

Mechanical Model of Domestic Gas Explosion Load

Experimental study on the flame-dual field overpressure coupling evolution characteristics of LPG/DME blended gas explosion venting

Gas Explosion Venting of Premixed Gases in Linked Vessels

Explosion Load Characteristics of Fuel—Air Mixture in a Vented Chamber: Analysis and New Insights

Experimental and numerical study on the effect of low vent burst pressure on vented methane-air deflagrations

Experimental Study on Premixed Flammable Gas Explosion Venting in Linked Vessels under the Same Effictive Vent Area

Evaluation of unrestricted hydrogen and hydrogen-methane explosion venting through duct