Abstract:Synthesis of thin zeolite membranes in the sub-micron range is desirable but a great challenge. Despite the successful synthesis of ultrathin Silicalite-1 and CHA membranes, the pursuit of SAPO-34 membranes thinner than 1 μm remains difficult. Herein, thin SAPO-34 membranes were prepared in concentrated gel by conventional hydrothermal synthesis. Concentrated membrane gel (TEAOH/Al2O3 = 4 and H2O/Al2O3 = 10) enhanced nucleation and facilitated the formation of small SAPO-34 crystals and therefore thin membranes. High TEAOH/Al2O3 ratio and special mixing sequence resulted into a homogeneous membrane gel with low viscosity which is beneficial for membrane synthesis with high reproducibility. Al(OH)3 as Al source led to formation of cubic SAPO-34 crystals which facilitated crystal intergrowth and reduced defects. These membranes (∼1.2 μm thick) exhibited high CO2 permeance of 3.9 × 10−6 mol/(m2 s Pa) and CO2–CH4 selectivity of 152 for equimolar CO2–CH4 mixture at room temperature and 0.14 MPa pressure drop. Further optimization of aging treatment or limiting the excessive membrane growth by a two-step hydrothermal synthesis + dry gel conversion method, the membrane thickness was successfully reduced to ∼0.9 μm, which increased the CO2 permeance to ∼5.0 × 10−6 mol/(m2 s Pa) without sacrificing CO2–CH4 selectivity.

Reproducible synthesis of all-silica CHA zeolite membranes in a homogeneous mother liquor

Seeded synthesis of all-silica CHA zeolites in diluted mother liquor

High-performance zeolite membranes on inexpensive large-pore supports: highly reproducible synthesis using a seed paste.

The preparation of zeolite NaA membranes on the inner surface of hollow fiber supports

Preparation of high-performance zeolite NaA membranes in clear solution by adding SiO2 into Al2O3 hollow-fiber precursor

Effects of the synthesis hydrogel on the formation of zeolite LTA membranes

Fast synthesis of thin SSZ-13 membranes by a hot-dipping method

ZSM-5 zeolite membranes prepared from a clear template-free solution

Fast synthesis of thin all-silica DDR zeolite membranes with inorganic base as mineralizing agent for CO2-CH4 separation

Efficient synthesis of thin SSZ-13 membranes by gel-less method

Improved Synthesis of Hollow Fiber SSZ‐13 Zeolite Membranes for High‐Pressure CO2/CH4 Separation

Synthesis of thin SAPO-34 zeolite membranes in concentrated gel

Fast synthesis of thin Silicalite-1 zeolite membranes at low temperature

Preparation of zeolite MFI membranes on alumina hollow fibers with high flux for pervaporation

Induction of Zeolite Membrane Formation by Implanting Zeolite Crystals into the Precursor of Ceramic Supports

High-Performance Zeolite Naa Membranes on Polymer-Zeolite Composite Hollow Fiber Supports

Synthesis and Low-Temperature Detemplation of High-Silica Mfi Zeolite Membranes

Zeolite membranes on hollow fiber supports

Manipulation of the Surface Microstructure and Its Effects on the Flux of NaA Zeolite Membranes in Pervaporation

Preparation of zeolite MFI membranes on defective macroporous alumina supports by a novel wetting–rubbing seeding method: Role of wetting agent

Sustainable synthesis of highly water-selective ZSM-5 membrane by wet gel conversion