Abstract:Underwater docking greatly facilitates and extends operation of an autonomous underwater vehicle (AUV) without the support of a surface vessel. Robust and accurate control is critically important for docking an AUV into a small underwater funnel-type dock station. In this paper, a docking system with an under-actuated AUV is presented, with special attention paid to control algorithm design and implementation. For an under-actuated AUV, the cross-track error can be controlled only via vehicle heading modulation, so both the cross-track error and heading error have to be constrained to achieve successful docking operations, while the control problem can be even more complicated in practical scenarios with the presence of unknown ocean currents. To cope with the above issues, a control scheme of a three-hierarchy structure of control loops is developed, which has been embedded with online current estimator/compensator and effective control parameter tuning. The current estimator can evaluate both horizontal and vertical current velocity components, based only on the measurement of AUV’s velocity relative to the ground; in contrast, most existing methods use the measurements of both AUV’s velocities respectively relative to the ground and the water column. In addition to numerical simulation, the proposed docking scheme is fully implemented in a prototype AUV using MOOS-IvP architecture. Simulation results show that the current estimator/compensator works well even in the presence of lateral current disturbance. Finally, a series of sea trials are conducted to validate the current estimator/compensator and the whole docking system. The sea trial results show that our control methods can drive the AUV into the dock station effectively and robustly.

Dynamics and control of underwater manipulators considering interaction between soft-body link and fluid flow

Motion Control of Docking Auv in Currents

Dynamic Analysis of an Underwater Cable-Driven Manipulator with a Fluid-Power Buoyancy Regulation System

Sliding Mode Control for Underwater Multi-DoF Hydraulic Manipulator

Electromechanical Control and Stability Analysis of A Soft Swim-Bladder Robot Driven by Dielectric Elastomer

Simplified Dynamical Model and Experimental Verification of an Underwater Hydraulic Soft Robotic Arm

Dynamical Characteristics of a Hydraulic Soft Actuator with Three Degrees of Freedom

Hydrodynamic analysis and manipulation control on a streamlined I-AUV

Dynamic Modeling and Vibration Suppression for Two-Link Underwater Flexible Manipulators

A Strong Underwater Soft Manipulator with Planarly-bundled Actuators and Accurate Position Control

A fluid-structure interaction study of soft robotic swimmer using a fictitious domain/active-strain method.

Advanced Motion Control of Hydraulic Manipulator with Precise Compensation of Dynamic Friction

Dynamic Modeling and Simulation of Underwater Parallel Robot.

Hierarchical Decoupling Controller with Cylinder Separated Model of Hydraulic Manipulators for Contact Force/Motion Control

Dynamic Analysis on Fingers of the Underwater Multi-fingered Robot Hand

Hybrid Motion/Force Control of the Hydraulic Cooperative Manipulator in Constrained Motion

On dynamic coupling effects of underwater vehicle-dual-manipulator system

An Adaptive Controller with Disturbance Observer for Underwater Vehicle Manipulator Systems

The Adaptive Robust Control of Deep-Sea Hydraulic Manipulator with Velocity Observer

Underwater Docking of an Under-Actuated Autonomous Underwater Vehicle: System Design and Control Implementation

Design, modeling, and control of underwater stiffness-enhanced flexible manipulator