Abstract:Heavy metals accumulated in slurry of dual alkali flue gas desulfurization (FGD) present a significant catalysis to SO3(2-) oxidation, resulting in a waste of effective components for desulfurization. Na2S was adopted to precipitate heavy metal ions in FGD slurry, and the oxidation rate of SO3(2-) was obtained under different concentrations of heavy metal ions, to reveal the inhibition effect of Na2S on SO3(2-) oxidation catalyzed by heavy metal ions. Mn2+ showed a remarkable catalysis to SO3(-2) oxidation, as the initial oxidation rate of SO3(2-) was tripled to 0.65 mmol/(L x min) by adding 1.0 mmol/L Mn2+ into the slurry. SO3(2-) was catalytically oxidized rapidly with the reaction order 0.169 of Mn2+ within first 60 minutes, so it is of great importance to control the concentration of Mn2+ to inhibit SO3(2-) oxidation. At initial pH value of 6.50-8.50, Na2S removed heavy metal ions effectively from FGD slurry. Higher pH value favored the removal of heavy metal ions. The removal efficiencies of Mn2+, Zn2+, Ni2+ and Cd2+ were 91.0%, 88.1%, 85.5%, and above 99.9% respectively under the conditions of initial pH value 8.50 and Na2S dosage 240.0 mg/L. Mn2+ could be used as an indicator for the concentration of the heavy metal ions in the slurry. As the Mn2+ concentration decreased from 1.0 mmol/L to 5.0 x 10(-3) mmol/L by adding Na2S, the initial oxidation rate of SO3(2-) decreased by 64.6% to 0.23 mmol/(L x min). The desulfurization efficiencies increase 3.8%-5.1% by adding Na2S in a pilot scale setup. It comes to conclusion that heavy metal ions precipitation by adding Na2S with an indicator of Mn2+ to inhibit catalytic oxidation of SO3(2-) is feasible to reduce the consumption of desulfurizer in FGD slurry.

Macrokinetics of ammonium sulfite oxidation inhibited by sodium thiosulfate in wet ammonium flue gas desulfurization

Study and optimization of catalytic oxidation technology in spent caustic desulfurization

Oxidation Inhibition of Sulfite in Dual Alkali Flue Gas Desulfurization System.

A Pilot Investigation on Oxidation of Ammonium Sulfite by Streamer Corona Plasma

[Inhibition of Sulfite Oxidation Catalyzed by Heavy Metals in Dual Alkali Flue Gas Desulfurization Slurry].

Inhibiting oxidation and enhancing absorption characteristics of sodium sulfite for SO2 removal from the non-ferrous smelting flue gas

Performance of Sulfate-Dependent Anaerobic Ammonium Oxidation

Experimental and kinetics of the oxidation of ammonium sulfite by hydrogen peroxide in ammonia flue gas desulfurization

Kinetics of the sulfite forced oxidation reaction with Co2+ and Mn2+ catalyst

Mechanism and Kinetics of Sulfite Oxidation in the Presence of Ethanol

Mass Transfer and Kinetics Study on the Sulfite Forced Oxidation with Manganese Ion Catalyst

Low-temperature oxidation behavior and mechanism of semi-dry desulfurization ash from iron ore sintering flue gas

Experimental investigation of sulfite oxidation enhancement in a micro-pore aeration system

Study on Fine Particles Influence on Sodium Sulfite and Oxygen Gas-Liquid Reaction

Kinetics and Mechanism of Sulfite Oxidation in the Magnesium-Based Wet Flue Gas Desulfurization Process

Study on the Reaction Rate of Sulfite Oxidation with Cobalt Ion Catalyst

Kinetics of the iron(II)- and manganese(II)-catalyzed oxidation of S(IV) in seawater with acetic buffer: A study of seawater desulfurization process

Oxidation of High Concentration Sulfites by Gas Discharge

Macrokinetics of magnesium sulfite oxidation inhibited by ascorbic acid.

Kinetics of NOx absorption into (NH4) 2SO3 solution in an ammonia-based wet flue gas desulfurization process

Intrinsic Oxidation Kinetics of Sulfite Catalyzed by Peracetic Acid under Different Water Quality and Light Conditions