Abstract:Results are presented for modelling of the evaporation and magnetron sputter deposition of Zn(x)O(y) onto an O-terminated ZnO (0001¯) wurtzite surface. Growth was simulated through a combination of molecular dynamics (MD) and an on-the-fly kinetic Monte Carlo (otf-KMC) method, which finds diffusion pathways and barriers without prior knowledge of transitions. We examine the effects of varying experimental parameters, such as substrate bias, distribution of the deposition species and annealing temperature. It was found when comparing evaporation and sputtering growth that the latter process results in a denser and more crystalline structure, due to the higher deposition energy of the arriving species. The evaporation growth also exhibits more stacking faults than the sputtered growth. Post-annealing at 770 K did not allow complete recrystallization, resulting in films which still had stacking faults where monolayers formed in the zinc blende phase, whereas annealing at 920 K enabled the complete recrystallization of some films to the wurtzite structure. At the latter temperature atoms could also sometimes be locked in the zinc blende phase after annealing. When full recrystallization did not take place, both wurtzite and zinc blende phases were seen in the same layer, resulting in a phase boundary. Investigation of the various distributions of deposition species showed that, during evaporation, the best quality film resulted from a stoichiometric distribution where only ZnO clusters were deposited. During sputtering, however, the best quality film resulted from a slightly O rich distribution. Two stoichiometric distributions, one involving mainly ZnO clusters and the other involving mainly single species, showed that the distribution of deposition species makes a huge impact on the grown film. The deposition of predominantly single species causes many more O atoms at the surface to be sputtered or reflected, resulting in an O deficiency of up to 18% in the deposited film and therefore resulting in more stacking faults and phase boundaries. The methods used allow analysis of key mechanisms that occur during the growth process and give hints as to the optimum conditions under which complete crystalline layers can form.

Chemical-etch-assisted growth of epitaxial zinc oxide

Low-Temperature Epitaxy Of Zno Films On Si(001) And Silica By Reactive E-Beam Evaporation

Epitaxial Growth Of Zno On Gan/Sapphire Substrate By Radio-Frequency Magnetron Sputtering

Low-temperature epitaxy of ZnO films on Si(0 0 1) and silica by reactive e-beam evaporation

Modelling the growth of ZnO thin films by PVD methods and the effects of post-annealing

B23-O-15 Van Der Waals Epitaxial Growth of Highly-textured ZnO Thin Film on Surface-modified Silicon Substrates by Chemical Bath Deposition

Epitaxial Deposition of Zn (0 0 2) for Stable Zinc Metal Anodes

Homoepitaxy of ZnO: from the substrates to doping

Competitive Adsorption and Two-Site Occupation Effects in Metal-Organic Chemical Vapor Deposition of Zno

Growth of high-quality ZnO thin films on (11\bar{2}0) a-plane sapphire substrates by plasma-assisted molecular beam epitaxy

The growth of nanoscale ZnO films by pulsed-spray evaporation chemical vapor deposition and their structural, electric and optical properties

Optimization study of metal-organic chemical vapor deposition of ZnO on sapphire substrate

Extending the kinetic and thermodynamic limits of molecular-beam epitaxy utilizing suboxide sources or metal-oxide catalyzed epitaxy

ZnO-Controlled Growth of Monolayer WS2 Through Chemical Vapor Deposition

Growth of High-Quality ZnO Thin Films on ( 112̅0 ) A-Plane Sapphire Substrates by Plasma-Assisted Molecular Beam Epitaxy

Epitaxial and layer-by-layer growth of EuO thin films on yttria-stabilized cubic zirconia (001) using MBE distillation

In Situ Study of Epitaxial Growth of ZnO Nanowires at the Junctions of Nanowall Networks on Zinc Particles.

Initial growth behavior and resulting microstructural properties of heteroepitaxial ZnO thin films on sapphire (0001) substrates

Systematic Investigation of the Growth Kinetics of Β -Ga2o3 Epilayer by Plasma Enhanced Chemical Vapor Deposition

Direct Observation of the Layer-by-Layer Growth of ZnO Nanopillar by In situ High Resolution Transmission Electron Microscopy

Homoepitaxial growth of ZnO nanostructures from bulk ZnO