Abstract:Compressed air foam (CAF) and compressed nitrogen foam (CNF) have been widely used for storage tank fire suppression, benefiting from their highly effective extinguishing performance. Mass loss rate is an important parameter to evaluate the stability of foam and an important factor to influence the suppression efficiency of foam. In this work, mass loss mechanisms including drainage and evaporation of two types of foams under a fixed radiation source were experimentally studied to reflect the foam fire suppression efficiency. It was observed that the foam drain rate is directly proportional to the foam mass, with a slight relation to the irradiance when irradiance is lower than 20 kW/m 2 . Once the irradiance reaches 30 kW/m 2 , the drain rate increases significantly. For evaporation, as expected from the established theoretical model, the evaporation rate shows a positive relationship with the irradiance level. However, there is no relationship between foam evaporation rate and the initial foam thickness. Through the experimentally measured evaporation rate, the average foam absorptivity is calculated to be approximately 0.63 ± 0.07 for both foams at an expansion ratio (ER) of 10. A comparative analysis of mass loss characteristics in the two types of foam was also undertaken. It was found that the two types of foam have distinct drain rates due to their different foam stability caused by the different expanded gas properties. However, they have a similar evaporation rate. In addition, the foam destruction rate and time to ignite the underlying fuel were measured, and a linear relationship between ignition time and initial foam height was found with a slope of 1.7 ± 0.2. The results demonstrate that CNF has a better fire suppression efficiency, which can be attributed to the better stability of the foam and the nitrogen released by broken bubbles, which inhibits ignition. The work presented here reveals the different functional mechanisms of compressed air/nitrogen foam and presents useful information that could enhance our understanding of the fire suppression effects of fire extinguishing foam.

Research on the influence of foaming gas in compressed air/nitrogen foam on extinguishing the n-heptane tank fire

A Theoretical and Experimental Study of Extinguishing Compressed Air Foam on an N-Heptane Storage Tank Fire with Variable Fuel Thickness

Flame Spreading and Burning of High- and Low-Flash Point Fuels under Compressed Air Foam Suppression

Suppression Behavior Difference Between Compressed Air/Nitrogen Foam over Liquid Fuel Surface Under Constant Radiation Heat Flux

Mechanism Insight of Shielded Methane Non-Premixed Jet Flame Extinction with Water Mist: OH-PLIF Visualization and Quantitative Analysis of Critical Fire Extinguishing

Experimental Study on Mass Loss Mechanism and Cooling Effect of Compressed Air Foam on Fuel Surface at Different Temperatures

Effect of liquid fuel on foamability and foam stability of mixtures of fluorocarbon and hydrocarbon surfactants

Experimental Study on Fire Extinguishing with a Newly Prepared Multi-Component Compressed Air Foam

Study on the flow characteristics of nitrogen gas foam in horizontal foam generator

Assessment of gas cooling capabilities of compressed air foam systems in fuel- and ventilation-controlled compartment fires

Experimental Study on the Characters and Fire Extinguishing Properties of a New High Spreading Aqueous Film Forming Foam(AFFF)

Full-scale Experimental Study on Flow and Fire Extinguishing Characteristics of Compressed Air Foam

Reliability study of fire suppression using dodecafluoro-2-methylpentan-3-one in small-sized confined space: From a temperature and gaseous products viewpoint

Influence of nanoparticles on the foam thermal stability of mixtures of short-chain fluorocarbon and hydrocarbon surfactants

Defoaming experimental study on several defoaming agents on compressed air foam

Experimental study of thermal stability and spread characteristics of gel-protein foam for liquid tank fires

Research on suppression effectiveness of compressed air foam for oil-immersed transformer hot oil fire

Comparative Study on Interfacial Properties, Foam Stability, and Firefighting Performance of C6 Fluorocarbon Surfactants with Different Hydrophilic Groups

Study on the Effect of Nanoparticles Combined with Silicone Surfactant and Cationic Surfactant on Foam and Fire Extinguishing Performance

Comprehensive Assimilation of Fire Suppression Modeling and Simulation of Radiant Fire by Water and Its Synergistic Effects with Carbon Dioxide

Tuning stability, rheology, and fire-extinguishing performance of advanced firefighting foam material by inorganic nanoparticle flame retardants