Abstract:Compressed air foam (CAF) and compressed nitrogen foam (CNF) have been widely used for storage tank fire suppression, benefiting from their highly effective extinguishing performance. Mass loss rate is an important parameter to evaluate the stability of foam and an important factor to influence the suppression efficiency of foam. In this work, mass loss mechanisms including drainage and evaporation of two types of foams under a fixed radiation source were experimentally studied to reflect the foam fire suppression efficiency. It was observed that the foam drain rate is directly proportional to the foam mass, with a slight relation to the irradiance when irradiance is lower than 20 kW/m 2 . Once the irradiance reaches 30 kW/m 2 , the drain rate increases significantly. For evaporation, as expected from the established theoretical model, the evaporation rate shows a positive relationship with the irradiance level. However, there is no relationship between foam evaporation rate and the initial foam thickness. Through the experimentally measured evaporation rate, the average foam absorptivity is calculated to be approximately 0.63 ± 0.07 for both foams at an expansion ratio (ER) of 10. A comparative analysis of mass loss characteristics in the two types of foam was also undertaken. It was found that the two types of foam have distinct drain rates due to their different foam stability caused by the different expanded gas properties. However, they have a similar evaporation rate. In addition, the foam destruction rate and time to ignite the underlying fuel were measured, and a linear relationship between ignition time and initial foam height was found with a slope of 1.7 ± 0.2. The results demonstrate that CNF has a better fire suppression efficiency, which can be attributed to the better stability of the foam and the nitrogen released by broken bubbles, which inhibits ignition. The work presented here reveals the different functional mechanisms of compressed air/nitrogen foam and presents useful information that could enhance our understanding of the fire suppression effects of fire extinguishing foam.

Research on suppression effectiveness of compressed air foam for oil-immersed transformer hot oil fire

Effectiveness Test and Evaluation of Transformer Fire Extinguishing System

Experimental Study on Fire Suppression of the Outdoor Oil-Immersed Transformer by High-Pressure Water Mist System

A Theoretical and Experimental Study of Extinguishing Compressed Air Foam on an N-Heptane Storage Tank Fire with Variable Fuel Thickness

Experimental Study on Fire Extinguishing with a Newly Prepared Multi-Component Compressed Air Foam

Experimental Study on Transformer Oil Pool Fire Suppression by Water Mist

Extinguishment of a Transformer Fire with a Long Projection Water Mist System

Experimental Study on Fire Hazard of High-temperature Transformer Oil Pool Fire and Exploration on Improvement of Fire-extinguishing System

Research on the influence of foaming gas in compressed air/nitrogen foam on extinguishing the n-heptane tank fire

Experimental Study on Mass Loss Mechanism and Cooling Effect of Compressed Air Foam on Fuel Surface at Different Temperatures

Experimental Study on the Characters and Fire Extinguishing Properties of a New High Spreading Aqueous Film Forming Foam(AFFF)

Assessment of gas cooling capabilities of compressed air foam systems in fuel- and ventilation-controlled compartment fires

Full-scale Experimental Study on Flow and Fire Extinguishing Characteristics of Compressed Air Foam

Study on the Inhibition Effect of C6F12O on Charged Particles in the Flame of Transformer Oil Discharge Gas

Flame Spreading and Burning of High- and Low-Flash Point Fuels under Compressed Air Foam Suppression

Suppression Behavior Difference Between Compressed Air/Nitrogen Foam over Liquid Fuel Surface Under Constant Radiation Heat Flux

Experimental study on extinguishing of pool fire with compressed air foam system in road tunnel

Scaled experimental study on the initial oil thickness effect on the combustion characteristic of the typical transformer insulating oil

Experimental investigation on the burning behaviors of thin-layer transformer oil on a water layer

Research Progress in Surface Flashover of Insulation Dielectric in Transformer Oil

Research review on Transformer Fire Protection Technology