Abstract:In this paper, a new ternary non-azeotropic mixture of HFC-161/125/143a (0.15/0.45/0.40 in mass fraction), as a promising mixed refrigerant to R404A, is presented. The ozone depletion potential (ODP) of the new refrigerant is zero and its basic thermodynamic properties are similar to those of R404A, but its global warming potential (GWP) is much smaller than those of R507A and R404A. Meanwhile, theoretical calculations show that, under the working condition I (the average evaporation temperature: −23 °C, the average condensing temperature: 43 °C, the superheat temperature: 28 °C, the subcooling temperature: 5 °C), the volumetric refrigerating effect and specific refrigerating effect of the new mixture are 2.33% and 15.48% higher, respectively, than those of R404A. The coefficient of performance (COP) of the new mixture is 5.19% higher than that of R404A and the pressure ratio of the new mixture is 0.82% lower than that of R404A. Equally, under the working condition II (the average evaporation temperature: −40 °C, the average condensing temperature: 35 °C, the superheating temperature: 30 °C, the subcooling temperature: 5 °C), the volumetric refrigerating effect and specific refrigerating effect of the new mixture are 2.24% and 20.58% higher, respectively, than those of R404A. The COP of the new mixture is 4.60% higher than that of R404A and the pressure ratio of the new mixture is similar to that of R404A. The performances of the new mixture and R404A are compared in a vapor compressor refrigeration apparatus originally designed for R404A under several working conditions (condensing temperatures: 35–45 °C, evaporation temperatures: −40–−20 °C). Experimental results show that the new mixture can obtain a higher COP, by 6.3% to 12.1%, and a lower pressure ratio, by 1.8% to 6.6%, compared to R404A; although the discharge temperature of the new mixture is slightly higher than that of R404A. The advantages of the new mixture will be further verified in the actual system.

High-glide refrigerant blends in high-temperature heat pumps: Part 1 – Coefficient of performance

Refrigerants And Heat Pumps For Efficient Use Of Low Grade Thermal Energy

A thermodynamic analysis of a transcritical cycle with refrigerant mixture R32/R290 for a small heat pump water heater

Use of Refrigerant Blends to Improve Thermal Efficiency of Heat Pump Cycles

Thermodynamic properties of non-azeotropic refrigerant heat pumps under full operating conditions with non-phase-change heat sinks and heat soucres

Thermodynamic analysis of a dual-pressure evaporation high-temperature heat pump with low GWP zeotropic mixtures for steam generation

Cycle Performance Studies on a New HFC-161/125/143a Mixture As an Alternative Refrigerant to R404A

Comprehensive performance evaluation method of working fluids for high temperature heat pump based on multi-objective optimization

Experimental and Theoretical Assessments on the Systematic Performance of a Single-Stage Air-Source Heat Pump Using Ternary Mixture in Cold Regions

Performance maximization by temperature glide matching in energy exchangers of cooling systems operating with natural hydrocarbon/CO2 refrigerants

Energy, Exergy, Economic and Environmental Studies on a Nonflammable Eco-Friendly Mixture for Efficient Heating in Cold Regions

Theoretical Study of HFO1336mzz(Z)/HFO1224yd(Z) Refrigerant Mixtures for High Temperature Heat Pump

A competitive study of a geothermal heat pump equiped with an intermediate economizer for R134a and R513A working fluids

Thermodynamic analysis and heat exchanger calculations of transcritical high-temperature heat pumps

Theoretical study of low-GWP refrigerants in high-temperature heat pump systems

Thermodynamic analysis of cascade high-temperature heat pump using new natural zeotropic refrigerant mixtures: R744/R600 and R744/R601

Thermodynamic analysis of novel mixtures including siloxanes and cyclic hydrocarbons for high-temperature heat pumps

PERFORMANCE ASSESSMENT OF RESIDENTIAL HEAT PUMPS OPERATING IN EXTREME COLD CLIMATES USING ZEOTROPIC MIXTURES {fr}ÉVALUATION DE LA PERFORMANCE DES POMPES À CHALEUR RÉSIDENTIELLES FONCTIONNANT AVEC DES MÉLANGES ZÉOTROPIQUES DESTINÉES AU CLIMAT EXTRÊMEMENT FROID

An experimental investigation of secondary fluid parameters on heat pumps with higher temperature lift and zeotropic working fluid

Thermodynamic performance of heat pump with R1234ze(E)/R1336mzz(E) binary refrigerant

Thermodynamic analysis of CO<sub>2</sub> blends for vehicle heat pump at cold ambient temperature