Abstract:Low global warming potential (GWP) refrigerants are vital to mitigating the effect of heat systems on climate change. A low GWP mixture, RGT2 (R134a/R1234yf/R161, 54%/43%/3% weight), was proposed as an alternative refrigerant for R134a in heat pump systems. This article presented the results of an experimental investigation evaluating RGT2 as a possible replacement for R134a in a closed heat pump drying (CHPD) system and studying the drying characteristics of fig slices. The experiment concluded that RGT2 has a higher coefficient of performance (COPhp) value than R134a, on average, by 1.92%, achieving lower discharge temperature and pressure ratio at different condensing temperatures (45 degrees C-70 degrees C). Although the heating capacity of RGT2 was slightly lower, it still met the requirements of HPD. With careful consideration of the environment, performance, and safety, RGT2 was a suitable substitute for R134a in the drying field. In addition, the drying characteristics of fig slices were significantly affected by the air temperature. The effective diffusion coefficient (D-eff) and specific moisture extracted ratio (SMER) are increased by increasing temperature and air flow rate. The two-term model was the better model to accurately predict the fig slices drying process. The highest mean D-eff and SMER of CHPDS were obtained as 6.4518 x 10(-10) m(2)/s and 39.197 g/kWh, respectively, at the highest drying air temperature. Practical Application A mixed refrigerant (RGT2) was proposed to replace R134a, and its GWP value was about 61% lower than that of R134a. Most of the studies on substituting R134a in the literature are simulations. This paper aims to evaluate the substitutions' feasibility theoretically and experimentally. The results have been assessed to provide better information about RGT2 as a potential substitute for R134a with superior comprehensive performance. Drying kinetics has also been determined experimentally, which helped to simulate fig drying. This study will provide a reference for refrigerants replacement in heat pump drying.

Theoretical study of low-GWP refrigerants in high-temperature heat pump systems

Refrigerants And Heat Pumps For Efficient Use Of Low Grade Thermal Energy

A thermodynamic analysis of a transcritical cycle with refrigerant mixture R32/R290 for a small heat pump water heater

Experimental study of ternary mixture R32/R125/R161 as alternative refrigerant to R407C

Experimental Evaluation on Low Global Warming Potential HFO-1336mzz-Z As an Alternative to HCFC-123 and HFC-245fa

Selection and Validation on Low-Gwp Refrigerants for a Water-Source Heat Pump

Theoretical Performance Assessment of Low-GWP Refrigerant R1233zd(E) Applied in High Temperature Heat Pump System

Theoretical Study of HFO1336mzz(Z)/HFO1224yd(Z) Refrigerant Mixtures for High Temperature Heat Pump

Theoretical Investigation and Comparative Analysis of the Linde–Hampson Refrigeration System Using Eco-Friendly Zeotropic Refrigerants Based on R744/R1234ze(Z) for Freezing Process Applications

Experimental performance of moderately high temperature heat pump with working fluid R1234ze(Z)

Experimental Assessment of a Low GWP Nonflammable New Refrigerant in a Closed Heat Pump Drying System

Study on the Performance of New High Temperature Heat Pump Mixtures as Alternatives to R245fa

Simulation Study on Performance of an Air Source Heat Pump System Combined with Phase Change Thermal Storage Using Alternative Refrigerants

Thermodynamic Investigation on Low GWP Drop‐in Alternatives to HFC‐245fa in Ejector Refrigeration Cycle for Air Condition Application

Comparison of Cycle Performance of HFO-1336mzz(Z)and HCFC-123 in Heat Pump System

Thermodynamic Performance Assessment of R32 and R1234yf Mixtures as Alternatives of R410A

Theoretical Study Of Heat Pump System Using R744/R1234yf As Refrigerant

Performance Enhancement Analysis of Environmentally Friendly Refrigerants

Investigation on Application of Refrigerant R1234ze in High-temperature Heat Pump

Vapor injected heat pump using non-azeotropic mixture R 32 / R 1234 ze ( E ) for low temperature ambient

Thermodynamic Cycle Performances Analysis of High Temperature Refrigerants in a Multi-Stage Heat Pump System