Abstract:Supported Mg-V-O oxides were prepared by co-impregnation of magnesium and vanadium citrates with MgOcoated mesoporous silica (SBA-15). Their structures were characterized by complementary techniques including powder X-ray diffraction, Raman spectroscopy, diffuse reflectance UV vis spectroscopy and transmission electron microscopy. These catalysts were examined in oxidative dehydrogenation (ODH) of propane to propylene, and the reaction kinetic parameters of k(1)/k(2) and kilki were analyzed, which represent the ratios of the rate constants for primary propane ODH (k(1)) to propane combustion (k(2)) and that for secondary propylene combustion (k(5)) to kb respectively. Characterization results show the structural evolution of the vanadium species from isolated VO4 monovanadates to Mg3V2O5 crystallites, without formation of crystalline V205, with increasing the vanadium content from 1.7 wt% to 25.6 wt%. Dispersed monovanadates exhibited higher propane ODH rates than Mg3V2O5 crystallites, in line with their higher reducibility probed by temperature-programed reduction in H2, but they were less selective to propylene due to the favorable propylene combustion over its formation, as reflected by the higher kilki ratios. The supported Mg3V2O5 crystallites with sizes of about 15-30 nm, relative to those of above 30 nm, were found to be intrinsically more selective for the propane ODH, consistent with their higher ki/k2 and lower kilki ratios. Consequently, they offered the superior selectivities and yields of propylene at higher propane conversions. Such understanding on the intrinsic catalytic properties of the Mg-V-O oxides and particularly Mg3V2O5 crystallites provides new insights into the structural requirement for the propane ODH reaction, beneficial to design of more efficient Mg-V-O-based catalysts for the production of propylene.

Investigations on the oxidative dehydrogenation of n-butane over VMgO-type catalysts

Oxidative dehydrogenation of n-butane on MgO-supported vanadium oxide catalysts

Influence of the Structural Characteristics of VPO Catalysts on the Temperature Sensitivity of the Oxidation Reaction of n-Butane to Maleic Anhydride

Oxidative dehydrogenation of n-butane on V/MgO catalysts. Influence of the type of contactor

Reaction Kinetics of N-Butane Oxidation on VPO Catalyst

Oxidative dehydrogenation of n-butane to butenes on Mo-doped VMgO catalysts

Oxidative Dehydrogenation of n-Butane: Activity and Kinetics Over VO x /Al2O3 Catalysts

MgO-modified VOx/SBA-15 as catalysts for the oxidative dehydrogenation of n-butane

Oxidative dehydrogenation of n-butane on V/MgO catalysts—kinetic study in anaerobic conditions

Effect of carbon dioxide on the reaction performance of oxidative dehydrogenation of n-butane over V-Mg-O catalyst

Oxidative Dehydrogenation of Cyclohexane to Cyclohexene over Mg-V-O Catalysts

Oxidative dehydrogenation of n-butane over mesoporous VO x /SBA-15 catalysts

Oxidative Dehydrogenation Of Ethane Over Modified Magnesium Oxides

Preparation of SBA-15-Supported Β-Mg2v2o7 Catalysts and Their Properties in Oxidative Dehydrogenation of Propane

Oxidative Dehydrogenation of Propane over Mg-V-O Oxides Supported on MgO-coated Silica: Structural Evolution and Catalytic Consequence

Investigation of the Selective Sites on Graphitic Carbons for Oxidative Dehydrogenation of Isobutane

A Fluidizable Catalyst for N-Butane Oxidative Dehydrogenation under Oxygen-Free Reaction Conditions

Biphasic Synergistic Effects of Mg-V-O Catalysts in Oxidative Dehydrogenation of Cyclohexane

Promoting Effect of Mg in Supported Mo/HBeta–Al2O3 Catalyst for Cross-Metathesis of Ethene and Butene-2 to Propene

Study of vanadium based mesoporous silicas for oxidative dehydrogenation of propane and n-butane

X-ray Photoelectron Spectroscopy and Catalytic Performance of Mg3 ( VO4 ) 2 Catalyst in Oxidative Dehydrogenation of Cyclohexane