Preparation of SBA-15-Supported Β-Mg2v2o7 Catalysts and Their Properties in Oxidative Dehydrogenation of Propane

Zhang Shenghong,Zhang Hongpeng,Sun Jiying,Liu Haichao

DOI: https://doi.org/10.3724/sp.j.1088.2010.00451

2011-01-01

CHINESE JOURNAL OF CATALYSIS (CHINESE VERSION)

Abstract:β-Mg2V2O7 catalysts supported on MgO-modified SBA-15 with V surface density of 4.1-8.5 nm-2 were synthesized by impregnation of the support with a pre-prepared aqueous solution of ammonium metavanadate,citric acid,and magnesium nitrate.The structure and reducibility of the catalysts were characterized by X-ray diffraction,Raman spectroscopy,diffuse reflectance UV-Vis spectroscopy,and temperature-programmed reduction in H2.For oxidative dehydrogenation(ODH) of propane,bulk β-Mg2V2O7 phase was much less active and selective than α-Mg2V2O7 although they have the same dimeric tetrahedral VO4 units connected by bridging V-O-V bonds.Compared to the bulk phase,the greater accessibility of V sites on the supported β-Mg2V2O7 catalysts led to an increase in not only the initial propane ODH rates by about 20 times but also the initial propene selectivity from 88.3 to 94.1%,as high as that for α-Mg2V2O7(94.6%) that has been considered as the most selective Mg-V-O phase for propane ODH reactions.The selectivity results are consistent with those reflected by the two kinetic parameters,k1/k2 and k3/k1,which represent the ratios of the rate constants for primary propane ODH(k1) to propane combustion(k2) and that for secondary propene combustion(k3) to k1.Such understanding on the intrinsic catalytic properties of the bulk and supported Mg2V2O7 catalyst provides useful information for design of new Mg-V-O-based catalysts,for example,dispersed α-Mg2V2O7 catalyst with high activity and selectivity for propane ODH reactions under mild conditions.