Abstract:The rheological properties of warm-mix recycled asphalt binders are critical to enhancing design quality and interpreting the performance mechanisms of the corresponding mixtures. This study investigated the rheological behavior of warm-mix recycled asphalt binders with high percentages of RAP binder. The effects of two warm-mix additives [wax-based Sasobit (S) and surfactant-based Evotherm-M1 (E)], a rejuvenating aging [ZGSB (Z)], four RAP binder contents (0%, 30%, 50% and 70%), and three aging states (unaged, short-term aged and long-term aged) were evaluated in detail using the dynamic shear rheometer (DSR), bending beam rheometer (BBR) and Brookfield rotational viscometer tests as well as conventional performance tests over the whole range of temperatures. The results showed that the rejuvenating agent Z effectively alleviated the aging effect of the RAP binder; however, it could hardly eliminate entirely this negative impact, especially at higher RAP binder contents. The addition of S remarkably lowered the apparent viscosity of the warm-mix recycled binders by up to 35.0%, whereas E had little influence on the binder viscosity due to its surfactant nature. Besides, S performed much better in improving rutting resistance (with the increase of up to 411.3% in |G*|/sinδ) than E, while E exhibited superior fatigue performance (with the reduction of up to 42.3% in |G*|·sinδ) to that of S. In terms of the thermal cracking resistance, E had very slight influence and S even yielded an adverse impact (with the increase of up to 70.2% in Sa and the decrease of up to 34.1% in m-value). Further, S broadened the ranges of pavement service temperatures by about 12 °C, whereas E almost did not change the PG grades of the binders. Finally, regarding the characteristics of viscoelastic master curves, S considerably improved the dynamic modulus and lowered the phase angle of the binders over a wide range of frequencies and temperatures but led to the failure of the time-temperature superposition principle due to its thermorheologically complex nature. Nevertheless, in this regard, the effect of E was found very mild.

Study on high-temperature performance evaluation of asphalt mixtures with anti-rutting additives

Evaluation of Crumb Rubber Modification and Short-Term Aging on the Rutting Performance of Bioasphalt

Nonlinear Viscoelastoplastic Kinetics for High-Temperature Performance of Modified Asphalt Binders

Research on High- and Low-Temperature Rheological Properties of High-Viscosity Modified Asphalt Binder

Investigation of the Effects of Nano-Al2o3 Addition on Compatibility, Rutting and Fatigue Properties of Styrene-Butadiene-rubber Modified Asphalt

Analysis on Impact of Gradation and Anti-rutting Additive on Rutting Resistance of Asphalt Mixture

Effect of Various Metal Hydroxide Flame Retardants on the Rheological Properties of Asphalt Binder

High-Temperature Rheological Characteristics of Asphalt Binder Incorporated with Graphene Oxide and Predicting Its Rutting Potential Using Response Surface Method

Laboratory and Field Investigation of the Feasibility of Crumb Rubber Waste Application to Improve the Flexibility of Anti-Rutting Performance of Asphalt Pavement

Effects of warm-mix asphalt technologies and modifiers on pavement performance of recycled asphalt binders

Performance Evaluation of Crumb Rubber Asphalt Modified with Silicone-Based Warm Mix Additives

Study on High Temperature Performance of Asphalt Mixture Based on Rutting Test

Evaluation of Performance on Crumb-Rubber-Modified Asphalt Mixture

Investigation into Rheological Behavior of Warm-Mix Recycled Asphalt Binders with High Percentages of RAP Binder

Improving the high-temperature performance of cold recycled mixtures by polymer-modified asphalt emulsion

Effect of Different Polymer Modifiers on the Long-Term Rutting and Cracking Resistance of Asphalt Mixtures

Study on Adhesion Performance and Aging Strength Degradation Mechanism of SBS Modified Asphalt with Different Anti-Aging Additive

Effect of crumb rubber and reclaimed asphalt pavement on viscoelastic property of asphalt mixture

Study on the performance and sustainability of modified waste crumb rubber and steel slag powder/SBS composite modified asphalt mastic

Reinforcement Effect of Different Fibers on Asphalt Mastic

Fatigue performance of long-term aged crumb rubber modified bitumen containing warm-mix additives