Abstract:The rheological properties of warm-mix recycled asphalt binders are critical to enhancing design quality and interpreting the performance mechanisms of the corresponding mixtures. This study investigated the rheological behavior of warm-mix recycled asphalt binders with high percentages of RAP binder. The effects of two warm-mix additives [wax-based Sasobit (S) and surfactant-based Evotherm-M1 (E)], a rejuvenating aging [ZGSB (Z)], four RAP binder contents (0%, 30%, 50% and 70%), and three aging states (unaged, short-term aged and long-term aged) were evaluated in detail using the dynamic shear rheometer (DSR), bending beam rheometer (BBR) and Brookfield rotational viscometer tests as well as conventional performance tests over the whole range of temperatures. The results showed that the rejuvenating agent Z effectively alleviated the aging effect of the RAP binder; however, it could hardly eliminate entirely this negative impact, especially at higher RAP binder contents. The addition of S remarkably lowered the apparent viscosity of the warm-mix recycled binders by up to 35.0%, whereas E had little influence on the binder viscosity due to its surfactant nature. Besides, S performed much better in improving rutting resistance (with the increase of up to 411.3% in |G*|/sinδ) than E, while E exhibited superior fatigue performance (with the reduction of up to 42.3% in |G*|·sinδ) to that of S. In terms of the thermal cracking resistance, E had very slight influence and S even yielded an adverse impact (with the increase of up to 70.2% in Sa and the decrease of up to 34.1% in m-value). Further, S broadened the ranges of pavement service temperatures by about 12 °C, whereas E almost did not change the PG grades of the binders. Finally, regarding the characteristics of viscoelastic master curves, S considerably improved the dynamic modulus and lowered the phase angle of the binders over a wide range of frequencies and temperatures but led to the failure of the time-temperature superposition principle due to its thermorheologically complex nature. Nevertheless, in this regard, the effect of E was found very mild.

Improving the high-temperature performance of cold recycled mixtures by polymer-modified asphalt emulsion

Evaluation of Crumb Rubber Modification and Short-Term Aging on the Rutting Performance of Bioasphalt

Nonlinear Viscoelastoplastic Kinetics for High-Temperature Performance of Modified Asphalt Binders

Effects of warm-mix asphalt technologies and modifiers on pavement performance of recycled asphalt binders

Quantitative assessment and mechanism analysis of modification approaches for cold recycled mixtures with asphalt emulsion

Study on the performance and sustainability of modified waste crumb rubber and steel slag powder/SBS composite modified asphalt mastic

Investigation into Rheological Behavior of Warm-Mix Recycled Asphalt Binders with High Percentages of RAP Binder

Experimental Study on Road Performance of Cold Recycled Asphalt Mixture with Emulsified Asphalt

Cracking Resistance of Recycled Rubber Asphalt Binder Composed of Warm-Mix Additives

Study on the Performance and Mechanism of Cold-Recycled Asphalt Based on Permeable Recycling Agent

Recycled Polyethylene and Crumb Rubber Composites Modified Asphalt with Improved Aging Resistance and Thermal Stability

Reclamation of waste oils in asphalt modification towards enhanced low-temperature performance of pavement in cold region

Using DSR and MSCR Tests to Characterize High Temperature Performance of Different Rubber Modified Asphalt

Laboratory and Field Research on Using Cement and Polyester Fiber to Enhance the Performance of Emulsified Asphalt Cold Recycled Mixture

Research on High-Temperature Rheological Properties of Emulsified Asphalt Mastics and Their Influencing Factors

Study on Cold Recycled Asphalt Mixtures with Emulsified/Foamed Asphalt in the Laboratory and On-Site

Performance evaluation of styreneic methyl copolymer regenerated SBS-modified asphalt and its mixture with high content RAP

Research on high and low temperature rheological properties of TPU/SBR composite modified asphalt

Experimental Investigation of the High-Temperature Rheological and Aging Resistance Properties of Activated Crumb Rubber Powder/SBS Composite-Modified Asphalt

Materials design and strength development of a novel cold recycled mixture with asphalt emulsion and geopolymer

Rheological and Aging Behaviors of Liquid Rubber Modified Asphalt Binders