Abstract:The rheological properties of warm-mix recycled asphalt binders are critical to enhancing design quality and interpreting the performance mechanisms of the corresponding mixtures. This study investigated the rheological behavior of warm-mix recycled asphalt binders with high percentages of RAP binder. The effects of two warm-mix additives [wax-based Sasobit (S) and surfactant-based Evotherm-M1 (E)], a rejuvenating aging [ZGSB (Z)], four RAP binder contents (0%, 30%, 50% and 70%), and three aging states (unaged, short-term aged and long-term aged) were evaluated in detail using the dynamic shear rheometer (DSR), bending beam rheometer (BBR) and Brookfield rotational viscometer tests as well as conventional performance tests over the whole range of temperatures. The results showed that the rejuvenating agent Z effectively alleviated the aging effect of the RAP binder; however, it could hardly eliminate entirely this negative impact, especially at higher RAP binder contents. The addition of S remarkably lowered the apparent viscosity of the warm-mix recycled binders by up to 35.0%, whereas E had little influence on the binder viscosity due to its surfactant nature. Besides, S performed much better in improving rutting resistance (with the increase of up to 411.3% in |G*|/sinδ) than E, while E exhibited superior fatigue performance (with the reduction of up to 42.3% in |G*|·sinδ) to that of S. In terms of the thermal cracking resistance, E had very slight influence and S even yielded an adverse impact (with the increase of up to 70.2% in Sa and the decrease of up to 34.1% in m-value). Further, S broadened the ranges of pavement service temperatures by about 12 °C, whereas E almost did not change the PG grades of the binders. Finally, regarding the characteristics of viscoelastic master curves, S considerably improved the dynamic modulus and lowered the phase angle of the binders over a wide range of frequencies and temperatures but led to the failure of the time-temperature superposition principle due to its thermorheologically complex nature. Nevertheless, in this regard, the effect of E was found very mild.

Selection of Optimal Warm-Mix Additive for Recycled Crumb-Rubber Modified Asphalt Binder Based on Rheological Tests and Viscoelastic Models

Evaluation of Crumb Rubber Modification and Short-Term Aging on the Rutting Performance of Bioasphalt

Cracking Resistance of Recycled Rubber Asphalt Binder Composed of Warm-Mix Additives

Research on High- and Low-Temperature Rheological Properties of High-Viscosity Modified Asphalt Binder

A New Eco-Friendly Porous Asphalt Mixture Modified By Crumb Rubber And Basalt Fiber

Effects of warm-mix asphalt technologies and modifiers on pavement performance of recycled asphalt binders

Rheology of Crumb Rubber-Modified Warm Mix Asphalt (WMA)

Study on the Properties of Waste Oil-Activated Crumb Rubber-Modified Asphalt Based on Molecular Dynamics Simulation and Rheology

Fatigue performance of long-term aged crumb rubber modified bitumen containing warm-mix additives

Performance Evaluation of Crumb Rubber Asphalt Modified with Silicone-Based Warm Mix Additives

Rheological Behaviour of WMA-Modified Asphalt Binders with Crumb Rubber

Rheological and environmental characteristics of crumb rubber asphalt binders containing non-foaming warm mix asphalt additives

Laboratory and Field Investigation of the Feasibility of Crumb Rubber Waste Application to Improve the Flexibility of Anti-Rutting Performance of Asphalt Pavement

Investigation into Rheological Behavior of Warm-Mix Recycled Asphalt Binders with High Percentages of RAP Binder

Decision support for selecting optimal method of recycling waste tire rubber into wax-based warm mix asphalt based on fuzzy comprehensive evaluation

Evaluation of Performance on Crumb-Rubber-Modified Asphalt Mixture

Effect of crumb rubber and reclaimed asphalt pavement on viscoelastic property of asphalt mixture

Workability and Mechanical Property Characterization of Asphalt Rubber Mixtures Modified with Various Warm Mix Asphalt Additives

Optimizing parameters for the preparation of low viscosity rubber asphalt incorporating waste engine oil using response surface methodology

Experiment and Representation of Stress Relaxation Behavior of Crumb Rubber Modified Asphalt

Preparation and modification mechanism study of microwave-treated crumb rubber and waste engine oil-modified asphalt