Abstract:In the context of global efforts to reduce carbon dioxide emissions, the periodic flow pattern and high mass transfer efficiency encountered in Taylor flow are considered in this work for the evaluation of new solvents for CO2 reactive absorption For this purpose, local values of the liquid-side mass transfer coefficient kL are provided for the CO2-NaOH-H2O system (liquid phase concentration: 0.25, 0.5, 0.7 or 1 M), in Taylor flow in a milli-channel. The experimental strategy is based on the shadowgraphy technique: the dynamic shrinkage of Taylor bubbles during CO2 uptake along the channel is recorded. The local mass transfer rate is deduced and compared to the overall rate estimated from the analysis of inlet and outlet liquid phase samples. In addition, the experimental results are compared with those obtained from the direct simulation of the reactive absorption, following the "unit cell approach". The computed distribution of reactant concentrations in the liquid phase clarifies the underlying local phenomena. The evaluation of the enhancement factor, which takes into account the changes in liquid phase composition along the channel, allows the estimation of the coefficient kL . For the present experimental campaign, the average enhancement factor (averaged over the channel length) is found to range between 2 and 15. This attests a fast chemical reaction – with regard to mass transfer – in the chosen conditions. Values of kL vary between 1.9·10 −5 and 2.8·10 −4 m.s −1 over the range of bubble velocity measured in the Region of Interrogation (0.05–0.4 m.s −1 ). The kL results obtained for the whole experimental campaign are then analyzed with respect to correlations issued from selected works of the literature and fitted according to relevant parameters. Thus, a novel scaling law is proposed to estimate the Sherwood number in reactive Taylor flow.

Chemisorption of CO 2 in a gas–liquid vortex reactor: An interphase mass transfer efficiency assessment

Liquid hydrodynamics in a gas-liquid vortex reactor

Prediction of formation of gas-phase bubbles correlated by vortices in the fuel reactor of chemical looping combustion

CO 2 capture in a novel rotating spiral contactor with hydraulic seal: Hydromechanics, mass transfer and modeling

Thermodynamic Exploration of Two-Stage Vacuum-Pressure Swing Adsorption for Carbon Dioxide Capture

Gas–liquid microdispersion and microflow for carbon dioxide absorption and utilization: a review

Gas-solid hydrodynamics in a stator-rotor vortex chamber reactor

A venturi reactor with an excellent mass transfer performance for carbon dioxide capture

CFD analysis on hydrodynamics and residence time distribution in a gas-liquid vortex unit

CO2 Capture in a Miniaturized Annular Rotating Device with Countercurrent Flow

Gas/Liquid Operations in the Taylor-Couette Disc Contactor: Continuous Chemisorption of CO2

A convenient method for measuring gas-liquid volumetric mass transfer coefficient in micro reactors

Experimental study of CO2 capture from air via steam-assisted temperature-vacuum swing adsorption with a compact kg-scale pilot unit

Intensified CO2 Absorption in a Microchannel Reactor under Elevated Pressures

Experimental investigation on continuous reaction crystallizer for CO2 capture by phase-change method

Experimental investigation of mass transfer efficiency in reactive Taylor flow for CO 2 absorption

Enhancing CO2 Conversion Via Atmospheric Pressure Glow Discharge Plasma Jet Coupled with Catalysts

Numerical Simulation of Carbon Dioxide (CO2) Absorption and Interfacial Mass Transfer Across Vertically Wavy Falling Film

Sorption-Enhanced Dry Reforming of Methane in a DBD Plasma Reactor for Single-Stage Carbon Capture and Utilization

Intrinsic Insight of Energy-Efficiency Optimization for CO2 Capture by Amine-Based Solvent: Effect of Mass Transfer and Solvent Regeneration

Structural Optimization of Reactor for the Enhancement of CO2 Electrochemical Reduction Based on Gas–Liquid Mixing Flow Model