Abstract:The dielectric and structural properties of the as-quenched melts of three CaO–B2O3–SiO2 compositions (denoted CBS-1, CBS-2, and CBS-3) were investigated to determine their suitability for use in millimeter-wave applications. The CBS-1 glass-ceramic exhibited the lowest coefficient of thermal expansion (CTE = 3.2 ppm/°C), lowest dielectric constant (εr = 4.04) at 60 GHz, and highest dielectric loss (tan δ = 0.0029) at 60 GHz, which were attributed to the presence of quartz (SiO2) as the major phase. In contrast, as the major phase constituent of the CBS-2 and CBS-3 glass-ceramics was β-CaSiO3, they presented relatively high CTEs (6.6 and 5.9 ppm/°C, respectively), relatively high dielectric constants at 60 GHz (6.29 and 7.61, respectively), and relatively low dielectric losses at 60 GHz (0.0020 and 0.0012, respectively). The CBS-1 glass-ceramic exhibited the highest dielectric loss because of the presence of SiO2 as the major phase constituent as well as lattice scattering induced by the high glassy phase content. The thermal conductivities (κ) of the CBS-1, CBS-2, and CBS-3 glass-ceramics were determined to be 2.43, 1.06, and 0.82 W/mK, respectively. Structural analysis using Raman and Fourier transform infrared spectroscopy revealed an absence of nonbridging oxygen in the CBS-1 glass-ceramic, while the high CaO content (>40 mol%) of the CBS-2 and CBS-3 glass-ceramics triggered the formation of nonbridging oxygen in the tetrahedral silicate units. The increase in CaO content of the glass-ceramics increased the number of nonbridging oxygen atoms, thereby resulting in the relaxation of the structure. Consequently, the CBS-2 and CBS-3 glass-ceramics exhibited low thermal conductivity. All the prepared glass-ceramics presented high electrical resistivities of greater than 5 × 1011 Ω cm. The CBS-1 glass-ceramic displayed the highest breakdown strength of 15.20 kV/mm. Overall, the excellent microwave dielectric properties and thermal properties of the CBS glass-ceramics will facilitate the utilization of these materials in millimeter-wave applications.

Silicate dielectric ceramics for millimetre wave applications

Low-temperature Co-Fired Ceramics with High Thermal Expansion and Reliability for Millimeter-Wave Antennas

Unleashing the Potential of Mg2SiO4-based Ceramics for Millimeter-Wave Applications: Achieving Ultra-Low Loss with Enhanced Temperature Stability Through Heterovalent Ion Substitution

Ultra low loss (Mg 1 − x Ca x ) 2 SiO 4 dielectric ceramics (x = 0 to 0.15) for millimeter wave applications

Low-loss dielectric ceramic materials and their properties

High-Qf value and temperature stable Zn2+-Mn4+ cooperated modified cordierite-based microwave and millimeter-wave dielectric ceramics

The latest process and challenges of microwave dielectric ceramics based on pseudo phase diagrams

Ultra Low Loss (mg1 − Xcax)2sio4dielectric Ceramics (x = 0 to 0.15) for Millimeter Wave Applications

Microwave dielectric properties and sintering behaviors of Zn1.8SiO3.8 ceramics

Principles of the development of a silica dielectric for microelectronics packaging

Crystal structure and phase formation of MgO–MoO3‐based ceramics with ultralow dielectric loss: A comprehensive study

Low-T Sintering, Low-Dielectric Materials for High Frequency Multilayer Chip Inductors

Silica-based ceramics toward electromagnetic microwave absorption

Cold sintering of microwave dielectric ceramics and devices

Low-permittivity BaCuSi4O10-based Dielectric Ceramics: an Available Solution to Connect Low Temperature Cofired Ceramic Technology and Millimeter-Wave Communications

Enhanced microstructure and dielectric properties of low-temperature sintered MgO-xwt%LiF ceramics for high-frequency applications

Microwave dielectric properties, vibrational spectrum, and antenna design of a novel melilite‐type Ba2CoSi2O7 ceramic

Microwave Dielectric Ceramics and Devices for Wireless Technologies

Dielectric properties of CaO–B2O3–SiO2 glass-ceramic systems in the millimeter-wave frequency range of 20–60 GHz

Hafnium silicate: a new microwave dielectric ceramic with low thermal expansivity

Spectroscopic properties and lattice dynamics of ferroelectric and related functional oxide ceramics