Abstract:Remote heteroepitaxy is known to yield semiconductor films with better quality. However, the atomic mechanisms in systems with large mismatches are still unclear. Herein, low-strain single-crystalline nitride films are achieved on highly mismatched (∼16.3%) sapphire via graphene-assisted remote heteroepitaxy. Because of a weaker interface potential, the in-plane compressive strain at the interface releases by 30%, and dislocations are prevented. Meanwhile, the lattice distortions in the epilayer disappear when the structure climbs over the atomic steps on substrates because graphene renders the steps smooth. In this way, the density of edge dislocations in as-grown nitride films reduces to the same level as that of the screw dislocations, which is rarely observed in heteroepitaxy. Further, the indium composition in InxGa1–xN/GaN multiquantum wells increases to ∼32%, enabling the fabrication of a yellow light-emitting diode. This study demonstrates the advantages of remote heteroepitaxy for bandgap tuning and opens opportunities for photoelectronic and electronic applications.The Supporting Information is available free of charge at https://pubs.acs.org/doi/10.1021/acs.nanolett.2c00632.Methods, batch synthesized graphene/sapphire composite substrates (Figure S1), Raman spectra of graphene (Figure S2), atomic characterizations of the interface (Figure S3), calculations of the lattice mismatch, out of plane lattice fluctuations (Figure S4), calculations about the offset and strains near steps (Figure S5), surface potential of monolayer graphene covered GaN (Figure S6), XRD of the as-grown GaN film and MQWs (Figure S7), In composition measurement of a traditional blue LED (Figure S8) (PDF)This article has not yet been cited by other publications.

Direct van der Waals epitaxy of stress-free GaN films on PECVD grown graphene

Microstructural and Optical Properties of Stress-Free GaN Films on Graphene Prepared by PECVD

Effect of Residual Stress on the Microstructure of GaN Epitaxial Films Grown by Pulsed Laser Deposition

The Effect of Gan Single Crystal Substrate Characteristics on Homo-Epitaxial Gan Films

Stress state of GaN epilayer grown on sapphire and 6H-SiC substrates

Stress and Its Effect on Optical Properties of GaN Epilayers Grown on Si(111), 6H-Sic(0001), and C-Plane Sapphire

Stress Study of GaN Grown on Serpentine-Channels Masked Si(111) Substrate by MOCVD

Fabrication of low stress GaN-on-diamond structure via dual-sided diamond film deposition

Direct Growth of GaN on Sapphire with Non-Catalytic CVD Graphene Layers at High Temperature

Epitaxial Growth of High-Quality GaN Films Based on Bilayer Graphene

Atomic Mechanism of Strain Alleviation and Dislocation Reduction in Highly Mismatched Remote Heteroepitaxy Using a Graphene Interlayer

GaN Epitaxial Layers Grown on Multilayer Graphene by MOCVD

Growth of Strain Free GaN Layers on (0001) Oriented Sapphire by Using Quasi-Porous GaN Template

Coordinated Stress Management and Dislocation Control in GaN Growth on Si (111) Substrates by Using a Carbon Nanotube Mask.

Interfacial stress characterization of GaN epitaxial layer with sapphire substrate by confocal Raman spectroscopy

Graphene-assisted remote epitaxy wrinkle-free GaN films on flexible mica

Stress Control in Gan Grown on 6H-Sic by Metalorganic Chemical Vapor Deposition

The investigation of stress in freestanding GaN crystals grown from Si substrates by HVPE

Stress and Morphology of a Nonpolara-Plane GaN Layer Onr-Plane Sapphire Substrate

Low-temperaturevan Der Waals Epitaxy of GaN Films on Graphene Through AlN Buffer by Plasma-Assisted Molecular Beam Epitaxy

High-quality GaN grown on nitrogen-doped monolayer graphene without an intermediate layer