Tiancheng Pu,Adhika Setiawan,Alexandre C. Foucher,Mingyu Guo,Jih-Mirn Jehng,Minghui Zhu,Michael E. Ford,Eric A. Stach,Srinivas Rangarajan,Israel E. Wachs
Abstract:The oxygen species on Ag catalysts and reaction mechanisms for ethylene epoxidation and ethylene combustion continue to be debated in the literature despite decades of investigation. Fundamental details of ethylene oxidation by supported Ag/α-Al(2)O(3) catalysts were revealed with the application of high-angle annular dark-field-scanning transmission electron microscopy-energy-dispersive X-ray spectroscopy (HAADF-STEM-EDS), in situ techniques (Raman, UV-vis, X-ray diffraction (XRD), HS-LEIS),...
What problem does this paper attempt to address?
This paper aims to solve the problems of the nature of active oxygen species and their reaction mechanisms in the ethylene epoxidation reaction over silver - based catalysts. Despite decades of research, the nature of oxygen species on silver catalysts and the reaction mechanisms of ethylene epoxidation and ethylene combustion are still controversial. In this paper, by applying high - angle annular dark - field scanning transmission electron microscopy - energy - dispersive X - ray spectroscopy (HAADF - STEM - EDS), in - situ techniques (such as Raman spectroscopy, ultraviolet - visible spectroscopy, X - ray diffraction (XRD), high - sensitivity low - energy ion scattering (HS - LEIS)), chemical probes (such as C2H4 - TPSR and C2H4+O2 - TPSR) and steady - state ethylene oxidation and SSITKA (16O2→18O2 switching) studies, the basic details of ethylene oxidation on supported Ag/α - Al2O3 catalysts are revealed.
### Main research contents:
1. **Catalyst characterization**:
- The fresh and used Ag/α - Al2O3 catalysts were characterized by HAADF - STEM - EDS, and it was found that the surface of Ag nanoparticles in the used catalyst contains a large amount of oxygen.
- The morphological changes of the catalyst indicate that the Ag nanoparticles undergo dynamic changes during the reaction, including sintering and pore formation.
2. **Properties of oxygen species**:
- Through the C18O2 exchange experiment and in - situ Raman spectroscopy, the existence of multiple active oxygen species was determined, and the concentrations of these species depend on the treatment conditions.
- Density functional theory (DFT) calculations show that under the reaction conditions, the oxidized - reconstructed p(4×4) - O - Ag(111) surface is more stable than the metallic Ag(111) surface.
- Selective ethylene oxidation to ethylene oxide (EO) only occurs when the Ag4−O2* species (the dioxygen species occupies the oxygen sites on the p(4×4) - O - Ag(111) surface) exists on the strongly oxidized Ag surface.
3. **Reaction mechanisms**:
- Ethylene epoxidation proceeds through the Langmuir−Hinshelwood mechanism.
- Ethylene combustion proceeds through the combined Langmuir−Hinshelwood (major) and Mars−van Krevelen (minor) mechanisms.
### Key conclusions:
- The selective reaction of ethylene epoxidation is mainly responsible for the surface Ag4−O2* species.
- Ethylene combustion involves surface and subsurface atomic oxygen (O*) species.
- These experimental results are strongly supported by the corresponding DFT calculations.
### Formulas and charts:
- **DFT calculations**:
- For example, the adsorption structures, binding energies and vibration frequencies of different oxygen species were calculated. Among them, the binding energy of the "vertical" species O2_O_sup is - 0.150 eV, and the binding energy of the "parallel" species O2_O_per is - 0.829 eV.
- The vibration frequencies in the Raman spectrum are consistent with the previously reported results. For example, the range of 750 - 800 cm⁻¹ corresponds to the oxygen species close to the subsurface level, and the range of 1050 - 1100 cm⁻¹ corresponds to the negatively charged surface oxygen species.
Through these studies, the author provides important basic data for the design of efficient ethylene oxide catalysts, which is helpful to improve process economy and reduce CO2 emissions.